85-03-01194
FV48
Page
87
6.7
REPLACEMENT PARTS INFORMATION
How to Access Components
The descriptions below show where the main fireplaces components are located and how to access them for service. The
descriptions show how to access the components after the fireplace has been installed. All components are also accessible from
the outside of the unit before the fireplace is installed.
Pilot
: The pilot is in the center of the firebox between the burners.
Gas Valve
: The main gas valve is located on the left side of the firebox. An inspection panel is provided on the left firebox wall
that allows inspection of the gas valve, wiring, and gas inlet connections.
Complete Valve Assembly
:
To make working on components easier, this fireplace has been designed with the valve, pilot,
shutter boxes, shutter cables and gas lines as part of one assemble that can be removed from the fireplace. To remove the
assembly first remove the inspection panel. This will allow the main gas inlet and wires to the valve, rear burner solenoid and
pilot to be disconnected. After disconnecting the gas line and wires remove the screws from the valve mounting plate (13 on the
left side and two on the floor of the firebox). Then remove the entire assembly from the firebox.
Ignition Control Module
: The ignition control module is mounted on the left on the floor under a heat shield. Access to the
ignition control module is available through the inspection panel. First remove the inspection panel. Then locate the two screws
holding the heat shield in place above the ignition control module. The ignition control module is affixed with Velcro to the floor.
Convection Blowers
: The convection blowers are mounted on t
he firebox’s rear
wall. To access the convection blowers, remove
the burners and airbox from the fireplace.
Accent Light
: The accent light is mounted in the firebox top center area. The accent light wire harness is run from the light
housing to the left side and then down to the ignition control module.
INSPECTION
PANEL
PILOT
FRONT BURNER
AIRBOX
CONVECTION
BLOWERS
REAR BURNER
