MCZ GARDENIA, Installation And User Manual

Page: 55 / 68

53
12-MAINTENANCE AND CLEANING
PERIODIC CLEANING PERFORMED BY A QUALIFIED TECHNICIAN
CLEANING THE HEAT EXCHANGER
Half-way through the winter season, but especially at the end of it, the compartment through which the exhaust smoke passes will need
to be cleaned. This cleaning process is mandatory in order to facilitate the general removal of all combustion residue, before it becomes
very difficult to remove it due to the humidity compacting it over time.
ATTENTION: For your safety, the frequency with which the exhaust smoke system is cleaned depends on the intensity
of use of the stove.
CLEANING THE EXCHANGER AND PIPE UNIT (PRIMULA/ORCHIDEA)
CLEANING THE UPPER COMPARTMENT
When the stove is cold, remove the top, remove the ceramics/sides, by loosening the relative fastening screws before removing the drivers
“
B ” and then remove the boiler cover “ C ” At this point, remove the four turbulators “ D ” and using a rigid rod or a bottle brush, clean the
internal pipe unit and the turbulators, removing all of the accumulated ash.
Check the cover gasket and replace it if necessary.
ATTENTION: It is advisable to carry out the cleaning of the upper exchanger at the end of the season and possibly by
an authorised technician in order to replace the gasket that is below plug “C”. (fig.11).
CLEANING THE LOWER COMPARTMENT
Remove the ash drawer “ G ”, empty it and using the nozzle of a vacuum cleaner remove any ash and soot that may have built up under the
drawer “ G ”. Remove the brazier “ F ” and clean it every 2/3 days.
Remove the drawer “
E
”, empty it and using the nozzle of a vacuum cleaner remove any ash that may have built up in the housing of the
drawer “
E
”.
ATTENTION: It is advisable to clean the lower compartment “E” once a week and in any case according to the fuel
consumption.
'*(63& ű $-&"/*/( 5)& 1*1& 6/*5 563#6-"5034 "/%
-08&3$0.1"35.&/5ŷ13*.6-"03$)*%&"Ÿ
Technical Dept. - All rights reserved - Reproduction is prohibited