5
Record your engine identification numbers on the
identification label below (Figure 4) for future
reference.
General Recommendations
Purchase gasoline in small quantities and store in
clean, approved containers. A container with a capacity
of 2 gallons or less with a pouring spout is
recommended. Such a container is easier to handle
and helps eliminate spillage during refueling.
Do not use gasoline left over from the previous season,
to minimize gum deposits in your fuel system and to
insure easy starting.
Do not add oil to the gasoline.
Do not overfill the fuel tank. Leave room for the fuel to
expand.
Fuel Type
For best results use only clean, fresh,
unleaded
gasoline with a pump sticker octane rating of 87 or
higher. In countries using the Research method, it
should be 90 octane minimum.
Unleaded gasoline is recommended as it leaves less
combustion chamber deposits. Leaded gasoline may
be used in areas where unleaded is not available and
exhaust emissions are not regulated. Be aware
however, that the cylinder heads may require more
frequent service.
Gasoline/Alcohol blends
Gasohol (up to 10% ethyl alcohol, 90% unleaded
gasoline by volume) is approved as a fuel for Kohler
engines. Other gasoline/alcohol blends are not
approved.
Gasoline/Ether blends
Methyl Tertiary Butyl Ether (MTBE) and unleaded
gasoline blends (up to a maximum of 15% MTBE by
volume) are approved as a fuel for Kohler engine.
Other gasoline/ether blends are not approved.
Engine Identification Numbers
When ordering parts, or in any communication
involving an engine, always give the
Model
,
Specification, and Serial Numbers
of the engine.
The engine identification numbers appear on a decal
affixed to the engine shrouding. Include letter suffixes,
if there are any.
Figure 4. Engine Identification Label.
The Emission Compliance Period referred to on the
Emission Control or Air Index label indicates the
number of operating hours for which the engine has
been shown to meet Federal and CARB emission
requirements. The following table provides the Engine
Compliance Period (in hours) associated with the
category descriptor found on the certification label.
Emission Compliance Period (Hours)
*Small Off-Road Engines
EPA
CARB
Category C
250 Hours
Moderate
125 Hours
Category B
500 Hours
Intermediate
250 Hours
Category A
1000 Hours
Extended
500 Hours
Refer to certification label for engine displacement.
Exhaust Emission Control System for models
CV11,12.5,13,14,15,16,CV460,CV490 is EM.
IMPORTANT ENGINE INFORMATION
THIS ENGINE MEETS U.S. EPA 2004 AND
CALIFORNIA 2006 AND LATER EMISSION
CONTROL REGULATIONS FOR SI SORE*
FAMILY
DISPL. (CC)
MODEL NO.
SPEC. NO.
SERIAL NO.
EMISSION COMPLIANCE PERIOD:
EPA:
CARB:
KOHLER CO. KOHLER, WISCONSIN USA
THIS ENGINE IS CERTIFIED TO OPERATE
ON:
REFER TO OWNER'S MANUAL FOR SAFETY,
MAINTENANCE SPECS AND ADJUSTMENTS.
FOR SALES/SERVICE IN US/CANADA, CALL:
1-800-544-2444
www.kohlerengines.com
N11236
