Kettler KB142-ZXRW, Translation Of The Original Operating Instructions

Page: 11 / 154

MY21K01 - 32_1.0_23.09.2020
11
Safety
2 Safety
2.1 Residual risks
2.1.1 Risk of battery fire and explosion
The safety electronics may fail if the batteries are
damaged or faulty. The residual voltage can
cause a short circuit. The battery may self-ignite
and explode.
 Only use and charge the battery and
accessories if they are in perfect condition.
 Never open or repair the battery.

Batteries with external damage must be
removed from service immediately.

If a battery is dropped or struck, remove it from
service and observe it for at least 24 hours.

Faulty batteries are hazardous goods. Dispose
of faulty batteries in the correct manner. Store
battery in a dry place until disposal. Never
store in the vicinity of flammable substances.
The battery is only protected from spray water.
Penetration by water can cause a short circuit.
The battery may self-ignite and explode.
 Never immerse the battery in water.

Put battery out of service if you suspect water
has penetrated it.
Temperatures over 60 °C can also cause liquid to
leak from the battery and the battery will become
damaged. The battery may self-ignite and
explode.

Protect the battery against heat.
 Never store next to hot objects.

Never expose the battery to sustained direct
sunlight.

Avoid wide temperature fluctuations.
2.1.2 Risk of fire and explosion due to
short circuit in the battery
Metal objects may connect the battery's electrical
terminals. The battery may self-ignite and
explode.

Never insert paper clips, screws, coins, keys
and other small parts into the battery.
Chargers with excessive voltage damage
batteries. This may result in fire or an explosion.

Only use batteries approved for the pedelec.
 Clearly label the supplied charger.
2.1.3 Fire hazard caused by overheated
charger
The charger heats up when charging the battery.
In case of insufficient cooling, this can result in fire
or burns to the hands.
 Never use charger on a highly flammable
surface.

Never cover the charger during charging.
 Never leave the battery unattended during
charging.
2.1.4 Electric shock caused by electric
drive system
Damaged chargers, cables and plug connectors
increase the risk of electric shock.
 Check the charger, cable and plug connector
before each use. Never use a damaged
charger.
If water penetrates into the charger, there is a risk
of electric shock.

Never charge the battery outdoors.