7
8
n
n
n
n
n
Storage tank must be cleaned once in 2
Replace RO membrane once in a year
weeks. (Refer Cleaning the water tank)
Replace UV Lamp once in a year
Replace sediment filter, activated carbon
In the event of not using purifier for a long
filter & post carbon filter once in 12 months
time (while going for a holiday, tour etc.),
or whenever the filter change alarm
make sure that you disconnect the power
activates. It is recommended to change
supply, turn off the raw water supply and
FRT along with the filters
drain the storage tank
Maintenance
The replacement time of consumables such as filters and membrane is dependent on the
quality of raw water and water consumed.
To ensure that the purifier operates at its BEST, a routine maintenance must be performed.
The frequency of the maintenance will greatly depend upon the raw water quality and consumption
of purified water.
Note: Filters and membrane are consumables. Their replacement time is dependent on the quality of raw water and
water consumption. They are not covered under the warranty. However, if a filter chokes within six months and a
membrane within a year, it will be cleaned/repaired/replaced free of cost. Changing the filters and system inspection is
available on call. The treatment capacity of RO membrane will reduce with time due to clogging of pores of
membranes.
“This reverse osmosis system contains a replaceable component critical to the efficiency of the system. Replacement
of the reverse osmosis component should be with one of identical specifications as defined by the manufacturer, to
ensure the same efficiency and contaminant reduction performance.”
Cleaning the Water Tank
The reverse osmosis system contains a replaceable treatment component critical for the effective reduction
of total dissolved solids and that product water shall be tested periodically to verify that the system is
performing properly.
Replacement of spare parts are as under:-
-20008
SP Inline Sediment Filter 10"
-20009
SP Inline Carbon Filter 8"
-20001
SP RO Membrane Welded 10" Housing
-20015
SP Post Carbon Filter (Blue)
-20003
SP Hollow Fibre Membrane (RO)
-20018
SP FRT 550
Open the Upper Cover
Remove the water Tank
Clean it under a running
tap water and wipe dry
Switch off the
power supply
Remove the Tank
Cover/Lid
Use white pipe for raw water supply
5. Now connect one end of white pipe to SS ball valve and other end to lower
elbow fitting connector labelled as
on the left side of purifier.
WATER IN,
Use blue pipe for reject water
6. Connect one end of blue pipe to upper elbow fitting connector labeled as
and lead the other end to drain.
7. Turn on the lever given on SS ball valve to initiate the water flow to purifier.
8. Allow the filters to pre-soak in water for 2-3 minutes.
9. Connect the power supply.
10. Installation is complete.
REJECT WATER
TDS Adjustment*
n
n
Turning the screw of the valve clockwise,
results in a decreased mineral content.
Turning the screw of the valve anti-clockwise,
results in an increased mineral content.
The unique TDS Control System enables customers to retain the contents of natural minerals (TDS)
in purified water, as per their requirement.
We recommend keeping the TDS at lowest but not below 50mg/l.
n
n
n
n
n
n
n
Switch on the power supply
Place back the storage tank and close the upper
cover
Allow the storage tank to fill to the maximum level**
Switch on the power supply
Switch off the power supply
Purifier is ready to use
Open the upper cover. Lift and drain the storage
tank so as to remove residual dust particles present
in the pipes and storage tank
Starting up the purifier
The glowing Red LED indicates power is on. The glowing Green LED indicates the
purification is on.
Recommended usage of Rejected Water
Although the rejected water has high concentration
The high concentration of salts and minerals
of salts, it is absolutely clean and free from
accelerate the plant growth. Rejected water can
impurities like chlorine, dirt, sand, etc. This rejected
also be used for cleaning utensils, mopping etc.
water usually goes down the drain but can be
used for gardening purpose.
* Tested & Certified by TUV-SUD South Asia (P) Ltd.
** Tested or certified flushing time - 24hrs.
