Commissioning
General guidelines for use
Before operation
Charge the solution and the refrigerant water if the solution and refrigerant water is in the barrels
during the delivery.
During commissioning, check the motor’s rotation direction of the solution pump, refrigerant
pump, and purge pump:
Note:
The flow of fluid cannot be seen because the solution and refrigerant pumps are
hermetically sealed.
CAUTION
Do not run the solution pump without solution.
Do not run the refrigerant pump without refrigerant water.
Use a rotation detector (Bell and Gosset or WILO DKG) to test the rotation direction. If a rotation
detector is not available, use the following procedure:
1. Remove the plugs at the solution and refrigerant sampling valves.
2. Make sure that the valves are completely closed.
3. Confirm that the absorber and refrigerant tank contain enough solution and refrigerant.
4. Connect a compound gauge (NPT 1/2 in.) to the sampling valve with Teflon tape.
Note:
The gauge’s scale must be -760 mmHg. to 2 Kg/cm
2
g, or -30 inches Hg. to 30 psig.
To prevent corrosion of the gauge, clean it thoroughly and check for leaks after use.
5. Operate the pump.
6. Open the valve.
7. Read and record the delivery pressure of the solution pump and the refrigerant pump.
8. Close the valve.
9. Check the pressure readings. See the following table to check if your pump's rotation is in the
right direction. The correct direction shows a higher discharge pressure.
Table 21: Rotary pump rotation
Correction rotation
Solution Circulation Pump
14.5 to 29 psig (0.1 to 0.2 MPaG)
Solution Spray Pump
13.8 psia to 2.9 psig (-0.05 to 0.02 MPaG)
Refrigerant Pump
13.4 psia to 2.9 psig (-0.08 to 0.02 MPaG)
10. Remove the compound gauge.
11. Put the plugs back on the valves.
97
YHAU-C Single Effect Steam-Fired Absorption Chiller
Summary of Contents for York YHAU-C
