Jackson Grills LUX700, Owner'S Manual

Page: 11 / 47

11
3.
Detach the regulator from tank valve by turning the black (QCC) nut counterclockwise.
4.
Install the protective cap back onto the threads of the propane cylinder valve.
Natural Gas Connection:
 FUEL TYPE:
The following instructions are for Natural Gas configured grills ONLY. Operating Pressure = 4” WC .
 INSTALLATION CODES:
Please refer to page three, item #1 of this manual.
 CONNECTING THE NATURAL GAS HOSE:
1.
Use only the natural gas hose supplied with your Natural Gas configured grill.
2.
Install the supplied hose onto the flare nut nipple on the fuel regulator, located on the RH inner side of the
pedestal. DO NOT USE SEALANT of any kind. Tighten using a ¾” open end wrench or a crescent wrench.
Hold the regulator nut with a second wrench while tightening.
3.
A female quick release (Hansen plug) is included with the grill. Install it onto the homeowner’s preexisting
natural gas quick release box. NOTE; pipe dope or Gas Rated Teflon tape must be used to seal the threads
at this connection.
4.
Check supply pressure to ensure that incoming pressure is no higher than 7” Water Column.
5.
Use a soapy water solution to check all connections for leaks before lighting grill. If a leak is found DO NOT
use the grill. Turn gas off and call a professional gas fitter to repair the leak.
!WARNING!
1 Never insert any foreign objects in valve outlet, as this
may cause leaks.
2 Do NOT connect this grill to unregulated Propane systems
such as in a motor home or camper trailer. System pressure
MUST be regulated before hook up.
3 Do NOT use this grill until leak tests have been completed.
4. If a gas leak is detected and cannot be stopped, call the
fire department.
!WARNING!
1 Never insert any foreign objects in the quick release or Natural Gas hose, as this
may cause leaks.
2 Pressure from the gas source for this grill MUST NOT exceed 14 inches of Water
Column; using a grill at higher pressures could result in property damage, and
injury or death.**
3 Do NOT use this grill until leak tests have been completed.
4. If a gas leak is detected and cannot be stopped, call the fire department
immediately
.
** NOTE; this is the maximum inlet pressure rating for the included Natural Gas
Regulator, part number JF
-
99