OIL FILTER
●
The engine oil and filter should be changed at those intervals specified in
the maintenance schedule. If the car is being driven in severe conditions,
more frequent oil and filter changes are required.
●
If the filter is blocked the warning light is on and if the oil pressure is low
the buzzer sounds at the same time. Replace it independent of the mileage.
●
An element assembly cannot be reused.
Replacement of filter type
1. Put an empty container below the oil filter drain hose. Remove the air
bleeding plug and drain the engine oil out.
2. Disassemble the case by pulling the center bolt on the oil filter out and re
鄄
move the element.
Use the genuine parts when you assemble. Replace the element and rub
packing of the case simultaneous. Apply engine oil on the rub packing before
assembling. Tighten the center bolt with specified torque 5.5
±
0.5 kg.m.
3. When you replace only the oil filter replenish the engine oil.
4. Crank the engine and check the oil leakage and the oil level later.
164
OWNER
’
S MANUAL
JAC HEAVY DUTY TRUCK
CAUTION
Be very careful when draining the engine oil as it may be hot enough to burn you.
Dropped oil may cause a fire. Wipe and clean each part in the engine room.
Replacement of cartridge type
If the filter is blocked, the warning light is on when the RPM is high.
Replace it independent of the mileage
If the oil pressure decreases the warning light also is on ant the buzzer sounds simultaneous. But the parking brake is
applied on it does not sound.
1. Put an empty container below the oil filter and remove the drain plug. Drain the engine oil out.
2. When the draining is finished pull the oil filter out with a wrench.
3. Use the genuine parts when you assemble. Assemble the rub packing on top of the filter after applying the engine oil
on.
4. When you replace the oil filter replenish the engine oil.
5. Start your engine. Check whether the oil leaks. The checking should be done before driving and after.
CAUTION
Split oil may cause a fire. Wipe and clean each part in the engine room.
Never reuse the filter assembly.
165
