- 5 -
CAUTION
•
Do not install or store the pump in the following places.
•
Places where flammable gas, dust or material is used or placed.
•
Places where corrosive gas (chlorine gas or the like) is generated.
•
Places where the ambient temperature is extremely high (40 °C or higher) or
extremely low, 0 °C or lower.
•
Places where the pump is exposed to extreme dust or humidity. (Excluding the out-
door type)
•
Places where vibrations occur.
•
Pump start-up
When connecting a power supply to the pump, make sure there is no person around
the pump. The pump has no ON/OFF switch. The pump starts operation when the
power is supplied by connecting the power supply cable.
•
Foreign matter
Should foreign matter enter the pump, turn off the power at once and remove the
obstruction. Using the pump with foreign matter inside may cause damage to the
pump or a malfunction.
•
Disposal of used pump
Disposal of used or damaged pumps must be done in accordance with local laws and
regulations. (Consult a licensed industrial waste products disposing company.)
•
The flange type motor is so heavy that it may fall over against the motor following dis-
assembly of the pump. Make sure to support the motor by using a crane or other
heavy-duty support system.
•
Handling of magnet coupling
The magnet used in the pump has a very high magnetic power. Be careful not to
allow your fingers to be seized by the magnet or to allow the magnet near any elec-
tronic device which may be affected by the magnet's power.
As a flange type driving magnet requires special equipment to hold it in place, do not
remove it from the shaft . In case removal is necessary, contact IWAKI or your deal-
er.
•
Suspending pump operation for a prolonged period
When suspending pump operation for a prolonged period, drain the pump and clean
inside the pump. Take appropriate measures to prevent the entrance of foreign mat-
ter into the pump. If the pump is not operated for a period longer than one year,
replace the gasket and inspect inside the pump.
Caution
Caution
Safety Section
Prohibited
