PAGE
62
THROTTLE SYSTEM
If the throttle pedal has excessive play due to either cable
stretch or maladjustment, it will cause a delay in throttle
response, especially at low engine speed. Also, the throttle
may not open fully. If the throttle pedal has no play, the
throttle may be hard to control, and the idle speed may be
erratic. Check the throttle play periodically and adjust if
necessary.
Throttle Pedal
Play Inspection
%
Put the gearshift level in the
Park position.
%
Start the engine.
%
Measure the distance the throttle pedal moves before
the engine begins to pick up speed. Free play should be
around 0.5 inches.
Adjusting Slack or Play in the Gas Pedal
Accessible under the hood, against the firewall, the throttle
cable on the gas and diesel machines can be adjusted on
the engine side and the foot pedal side.
%
Adjust the two jam nuts on the cable conduit.
%
The full throttle stop and the idle stop for the pedal are
adjusted by the 5/16˝ bolts in the mount assembly.
PAGE
63
BATTERY
DANGER:
The Battery emits explosive gases; flame is
strictly prohibited. The Battery contains sulfuric
acid (electrolyte) which can cause serious
burns, so be careful not to make contact with
your eyes or skin. If you get battery acid on
your skin, wash it off immediately with water.
If you get battery acid in your eyes, flush it out
immediately with water and then see a doctor.
Keep all flames and sparks, including
cigarettes, away from the battery.
Notice:
%
The battery requires maintenance.
%
Check the battery terminals and distilled water
levels monthly.
%
Do not allow any battery cell to run dry.
%
Keeping the battery terminals coated with
dielectric grease or petroleum jelly will prolong its
life.
PAGE
61
Summary of Contents for GC1K S1
Page 1: ...UTVRevised OWNER S MANUAL QWLPLGDWRU FF DV 2018...
Page 82: ...PAGE 82...
