15
NOTE
This machine is shipped
WITHOUT
Oil and Fuel and will require filling
BEFORE
use.
Failure to do so will result in engine damage that will not be covered by the warranty.
WARNING
You
MUST STOP
the machine if any of the following occur;
The engine speed changes with no control.
In case of misfire or unusual noise.
In case of high vibration.
In rain or stormy weather.
CAUTION
FOR OUTDOOR USE ONLY
This machine produces carbon monoxide
– a poisonous, colourless and odourless
gas that can cause death or serious injury.
Petrol is highly flammable, always handle with extreme care and in a well-ventilated
area.
ALWAYS
remove the HT lead from the spark plug when checking the machine,
refuelling or changing parts.
CAUTION
If you are not familiar with this type of machine, you should seek advice and
guidance from your dealer.
DO NOT
attempt to lift the machine with the engine running.
7.0
After the engine warms up, pull the throttle lever to accelerate the engine speed.
7.1
The plate will begin vibrating and begin to move forward.
7.2
The plate compactor is designed to run at an engine speed (engine take off shaft) of
3600rpm (normally considered full throttle).
7.3
Running the engines at lower rp
m’s will result in a decrease in compaction force and
a lower travel speed.
It will create excessive ‘out-of-sync’ vibrations resulting in poor compaction,
manoeuvrability, excessive wear to the machine and discomfort for the operator.
7.4
In operation, guide the machine but let the compactor do the work.
7.5
Bearing down on the handle is unnecessary and will cause shock absorber wear.
7.6
On level surfaces the compactor moves forwards rapidly.
7.7
On uneven surfaces or inclines, light forward pressure on the handle may be required
to assist the compactor in moving forward.
7.8
The number of passes required to reach a desired compaction level will depend on the
type and moisture content of the soil.
7.9
Maximum compaction has been reached when excessive kickback is noticed.
7. OPERATING INSTRUCTIONS
