42
© Erwin Hymer Group North America, Inc
o
Sanitize by adding 1/2 cup chlorine bleach to the tank, fill with water, let sit for at least two hours, and drain. 1/2 cup vinegar added to the next
tankful, which will also be drained before filling with fresh water for use, will help dissipate the chlorine smell.
Refer to other sections in this manual for drain and fill locations.
At Least Twice a Year
Check windshield wiper operation.
o
Clean wiper blades with clean cloth dampened with washer fluid.
o
Wiper blades should be replaced at least once a year.
Check radiator, heater and air-conditioning hoses for leaks or damage.
Check for worn tires and loose wheel lug nuts.
Check parking brake system and put the brake on and see if it will hold on a moderate hill. If not, get it repaired.
Check head lamp alignment.
o
Shine your low beam headlights on a wall. The light patterns should be the same height. Measure headlight height at the vehicle with a yardstick
and the light patterns should be the almost same height or slightly less with your vehicle level. If not, get the headlights aligned.
Check lap and shoulder belts for wear and function. Replace any belts with frayed spots or that do not smoothly retract into their holders.
Inspect appliance vents to ensure they are free from dirt, insects, spider webs and/or nests.
Inspect gray water tank vent and remove any debris or other obstructions. The gray water tank vent is on the roof, passenger side and in the bathroom
area.
Clean air conditioner filter. See air conditioner manual for details.
Thoroughly clean and wax the roof of the van.
o
To wash the solar panel, use a garden hose to rinse dirt off the panel.
o
Do not scrub it with a brush or otherwise apply any abrasive material to the solar panel surface.
o
Rinsing the panel two or three times a year to remove excess dirt is all you need to do to keep the panel operating at full output.
With the tank empty, add one cup of mineral oil and one cup of hot water to the gray tank.
At Least Once a Year
Lubricate all door hinges, locks and latches, especially the exposed hinges on exterior doors. These will freeze up and cause damage to the doors if
neglected.
Have appliances tested and cleaned.
Wax and polish and protect exterior surfaces. The wheels are coated aluminum and there is no bare aluminum on the vehicle, so do not use aluminum
polish on any surface of your Aktiv.
