C1000
- User Guide (636155)
Rev: 04 Nov 2019
Page: 18
Charging the lift
The light will turn ORANGE on the lift control
panel and a slow beeping audible alarm will sound
if the batteries are low and require charging. The
display screen will also indicate low battery.
Complete the transfer that is in progress and then
move lift to the end of the track where the charger
is located.
Following the ORANGE indicator, the light will
turn RED on the lift control panel and a fast beep-
ing audible alarm will sound indicating the batter-
ies are fully discharged and require charging. The
display screen will also indicate low battery.
When the battery is discharged the UP function
will be disabled. The DOWN and EMERGENCY
DOWN function along with X-Y TRAVERSING
will continue to operate.
Caution: Use only the Soneil charger that was supplied with the lift or with Mascot 9940 charger. Use
of any other charger will void all warranties and may cause damage to the lift.
Figure 10A - Underside of lift showing RED dis-
charged battery indicator light and audible alarm
beeping every 10 seconds.
The charger contacts with two metal charging strips that run along the inside of the track.
Whenever the lift is over a section of track with charging strips it will automatically start to charge
the lift if its battery is low.
The batteries should be charged on a regular basis. It is recommended that the lift be left on charge
when not in operation, and at the end of each day. This will maximize the life cycle of the batteries
The lift may remain connected to the charger indefinitely since the charger has a built-in regulator,
eliminating the danger of overcharging.
As a general rule it is recommended that the carry bar be raised to a height so that it will not
interfere with anything or anyone while the unit is not in use.
Display Screen
Allowable Charger Specifications:
-Soneil 2403SRM30, Input: 100-240Vac, 50/60Hz, 1.5A max, Output: +24Vdc, 1.5A
-Mascot 9940, Input : 100-240Vac, 50-60Hz, 0.9amp ; Output: 29.5Vdc, 1.3amp /
When the lift is on the charger the light on the lift will always be ORANGE. After one hour, the lift
may be used, however, overnight charging is recommended. The light will change to GREEN when
the lift is removed from the charger. This indicates that the lift is charged between 25%-100%.
