3
•
Never
connect an unregulated LP gas tank to
your gas grill. The gas Regulator assembly
supplied with your gas grill is adjusted to have
an outlet pressure of 11" water column (W.C.)
for connection to an LP gas tank.
•
Only use the Regulator and Hose Assembly
suppli ed wi th your gas gri ll . Replacement
Regulat ors and Hose Assembli es must be
those specified by manufacturer.
•
Have your LP gas tank filled by a reputable propane
g a s
d ea l er
a n d
v i s u a l l y
i n s p ec t e d
a n d
re-qualified at each filling.
•
Never fill the gas tank beyond 80% full.
Have your propane gas dealer check the release
valve after every filling to ensure that it remains
free of defects.
•
Always keep LP gas tanks in upright position.
•
Do not store (or use) gasoline or other flammable
vapors and liquids in the vicinity of this gas grill.
•
An LP gas tank that is not connected for use must
NOT be stored on bottom shelf inside cabinet or in
t he vi ci ni t y of t h i s or an y ot her gas gr i l l .
•
Do not subject the LP gas tank to excessive heat.
•
Never store an LP gas tank indoors. If you
store your gas grill in the garage or other indoor
location,
always
disconnect the LP gas tank
first, store it safely outside.
•
LP gas tanks must be stored outdoors in a
well-ventilated area and out of the reach of
children. Disconnected LP gas tanks must not
be stored in a building, garage or any other
enclosed area.
•
W hen your gas gri ll i s not i n use t he gas
must be turned off at the LP gas tank.
Proper Placement and Clearance of Grill
Never
use your gas grill in a garage, porch, shed,
breezeway or any other enclosed area. Your gas grill is to
be used
outdoors only
, at least 24 inches from the back
and side of any combustible surface. Your gas grill
should not be placed under any surface that will burn.
Do not obstruct the flow of ventilation air around the
gas grill housing.
This outdoor gas grill is not intended to be installed in
or on recreational vehicles and/or boats.
The LP gas tank has a Shut Off Valve, terminating
in an LP gas supply tank valve outlet, that is
compatible with a Type 1 tank connection device.
The LP gas tank must also have a safety relief
device that has a direct communication with the
vapor space of the tank.
The tank supply system must be arranged for
vapor withdrawal.
The LP gas tank used must have a collar
to protect the tank valve.
1.
2.
3.
•
The Regulator and Hose assembly must be
inspected before each use of the grill. If there
is excessive abrasion or wear or if the hose
is cut, it must be replaced prior to the grill
being used again.
•
Keep the gas Regulator Hose away from hot
gril l surfaces and dri ppi ng grease. Avoi d
unnecessary twisting of hose. Visually inspect
hose prior to each use f or cuts, cracks,
excessive wear or other damage. If the Hose
appears damaged do not use the gas grill, call
our Customer Service Dept. for a replacement,
at 1-800-667-7313.
•
Never
light your gas grill with the Lid closed
or before checking to insure the Burner Tubes
are fully seated over the Gas Valve Orifices.
•
Never
allow children to operate your grill. Do
not allow children to play near your grill.
Failure to comply with these instructions
could result in a fire or explosion that could
cause serious bodily injury, death, or prop-
erty damage.
WARNING
A strong gas smell, or the hissing sound of gas
indicates a serious problem with your gas grill
or the LP gas tank. Failure to immediately follow
the steps listed below could result in a fire or
explosion that could cause serious bodily
injury, death, or property damage.
NOTE:
The normal flow of gas through the
Regulator and Hose Assembly can create a
humming sound. A low volume of sound is
perfectly normal and will not interfere with opera-
tion of the grill. If humming sound is loud and
excessive you may need to purge air from the
gas line or reset the Regulator excess gas flow
device. This purging procedure should be done
every time a new LP gas tank is connected to
your grill. For help
call the Grill Information
Center.
Customer Service Dept., 8:00am-5:00pm
EST, Monday through Friday at:
1-800-667-7313
•
Shut off gas supply to the gas grill.
•
Turn the Control Knobs to OFF position.
•
Put out any flame with a Class B fire
extinguisher.
•
Open Grill Lid.
•
Get away from the LP gas tank.
•
Do not try to fix the problem yourself.
•
If odor continues or you have a fire you cannot
extinguish, call your fire department. Do not call
near the LP gas tank because your telephone is
an electrical device and could create a spark
resulting in fire and/or explosion.
WARNING
!
!
