Part 10 - Lighting the appliance / First start-up
Warning
Use of electrical connections to the boiler other than described might result in unpredictable behaviour,
or malfunction of the boiler.
DO NOT WIRE ANY VOLTAGE, ONLY DRY CONTACTS TO CONTROL
BOARD.
Warning
The boiler must be manually bled of air using the manual air bleed on top of the heat exchanger. Before
commission turn the manual air bleed until water pours out
. Make sure to perform this action before boiler
is
turned on in order to prevent hot water scalding.
Warning
Before Start-up refer to
Mandatory Pre-commissioning Procedure for Plastic Venting
in Section 4.0.
Failure to follow these instructions can result in explosions, injury or death.
Warning
Prior to turning the gas supply on and lighting the appliance, ensure all aspects of the installation are complete and in
conformance with the instructions provided in this manual, including the Vent/Air-Intake sections and the manuals
delivered with the vent system, Condensate Drain, and System Water Piping. Failure to precisely follow these
instructions will cause a fire or explosion resulting in property damage, serious injury or death.
Warning
Do not store or use gasoline or other flammable vapours & liquids in the vicinity of this or any other
appliance. Failure to follow instructions could result in explosion causing property damage, serious injury or
death.
Warning
If you do not follow these instructions exactly, a fire or explosion may result causing property damage,
serious injury or death.
Warning
Should overheating occur or the gas supply fail to shut off, turn off the manual gas control valve to the appliance.
Failure to follow instructions could result in explosion causing property damage, serious injury or death.
54