![background image](http://html1.mh-extra.com/html/gardner-denver/l160-110a-v2/l160-110a-v2_user-manual_3807675024.webp)
3
Design and function
24 / 72
America
January 2017
Function display on lubricator
1
2
4
3
1
5
[1]
Function display (LED)
[2]
Min. lubrication period from the vessel
change and count display of the last 100
operating hours of the lubricant vessel.
[3]
Lubricant quantity for 100 operating hours
[4]
Plug connector
[5]
“SET” key
The function display is only active if the screw air
compressor unit’s drive motor is running.
The lubricators are fitted with one red and one
green LED. These LEDs indicate the following
operating conditions or faults to the operator.
LED Signal
Explanation
Green Constant sig-
nal
OK. “System running”
Green Continu-
ous signal
<30sec.
Dispensing cycle
Red
Continu-
ous signal
>30sec.(*)
Fault/error
Red
Continuous
signal (*)
Grease cartridge empty,
please change
(*) When the lubricator issues this signal, the
following message is output on the compressor
control: [Warning: Mot.lubr. sys] (also refer to the
operating instructions for the compressor control
GD Pilot TS).
If the lubricant pipe is blocked, the drive unit
increases the pressure to 6bar / 87psi. If the max.
pressure is reached, the lubricator switches to
a special programme and attempts to open the
lubrication duct with three additional lubrications
within 48 hours. If this remains unsuccessful, the
unit reports a fault.
Special lubrication
If you push the “SET” key for 10 seconds, a
special lubrication takes place; e.g. for prefilling or
flushing a soiled lubrication point.
Lubricator operating parameters
The following setting applies to the screw air
compressor range L160-L290 / 50Hz + 60 Hz with
a standard electric motor:
Description
Value
Grease dispensing volume / 100
operating hours
2.7 cm³ /
0.17 in³
Pause time between two dispens-
ing processes
approx.
9 operating
hours
Grease cartridge service life
approx.
4,000 operat-
ing hours
3.8
Heat recovery L160-L290
WARNING
Contamination with Legionella
Health hazard with open-loop cooling
systems.
➯
Continuous monitoring of water
quality and germ count in the
cooling circuit.
Summary of Contents for L160 110A V2
Page 1: ...User manual Screw compressor L160 L290 V2 L160RS L290RS V2 America ZS1149274 03 January 2017...
Page 7: ...Foreword 1 January 2017 America 7 72 1 6 Rating plate Fig 1 1 Rating plate...
Page 69: ...Appendix 9 January 2017 America 69 72...
Page 70: ...9 Appendix 70 72 America January 2017...