![background image](http://html1.mh-extra.com/html/gardner-denver/auto-sentry-eau99g/auto-sentry-eau99g_operating-and-service-manual_3581467007.webp)
13-10-614 Page vii
LIST OF ILLUSTRATIONS
Figure 1-1 – Compression Cycle..........................................................................................................1
Figure 1-2 – Starter Box ......................................................................................................................3
Figure 1-3 – Package – Controller & Starters ........................................................................................3
Figure 1-4 – Package – Drive Motor & Air Filter.....................................................................................4
Figure 1-5 – Package – Oil Filter, Oil Level Gauge, Mixing Valve ...........................................................5
Figure 1-6 – Package – Air/Oil Flow Diagram........................................................................................5
Figure 2-1 – Typical Compressor Room ............................................................................................. 10
Figure 2-2 – Air Flow Chart ................................................................................................................ 10
Figure 2-3 – Cold Weather Installation................................................................................................ 12
Figure 2-4 – Inlet Line Lengths........................................................................................................... 13
Figure 2-5 – Heat Exchanger (Oil Cooler) Approximate Water Flow...................................................... 15
Figure 2-6 – Aftercooler Approximate Water Flow ............................................................................... 15
Figure 2-7 – Series Piping ................................................................................................................. 17
Figure 2-8 – Parallel Piping................................................................................................................ 17
Figure 4-1 – Schematic Tubing Diagram............................................................................................. 24
Figure 4-2 – Minimum Discharge Pressure/Check Valve...................................................................... 25
Figure 4-3 – Inlet Valve ..................................................................................................................... 26
Figure 4-4 – Shuttle Valve ................................................................................................................. 26
Figure 4-5 – Blowdown Valve............................................................................................................. 27
Figure 4-6 – Turn Valve Actuator (Sectioned)...................................................................................... 28
Figure 4-7 – Control Schematic – Compressor At Full Load ................................................................. 30
Figure 4-8 – Control Schematic – Compressor Fully Unloaded – Low Demand Mode Switch Off............ 31
Figure 4-9 – Control Schematic – Compressor Fully Unloaded – Low Demand Mode Switch On............ 32
Figure 4-10 – Wiring Diagram – (Wye Delta, ES+ Controller, Air-Cooled).............................................. 33
Figure 4-11 – Wiring Diagram – Wye Delta ES+ Controller – Water Cooled.......................................... 35
Figure 5-1 – Dew Point Chart
°
F ........................................................................................................ 39
Figure 5-2 – Dew Point Chart
°
C ........................................................................................................ 39
Figure 5-3 – Flow Diagram ................................................................................................................ 40
Figure 5-4 – Oil Flow Diagram – Remote Overhead Mounted............................................................... 41
Figure 5-5 – Cooler Drain Detail......................................................................................................... 42
Figure 5-6 – Oil Level Gauge ............................................................................................................. 46
Figure 5-7 – Oil Change Interval ........................................................................................................ 46
Figure 5-8 – Approximate Oil System Capacities................................................................................. 48
Figure 5-9 – Thermostatic Mixing Valve Element................................................................................. 50
Figure 5-10 – Water Control Valve ..................................................................................................... 52
Figure 5-11 – Oil Separator ............................................................................................................... 53
Figure 6-1 – Heavy Duty Air Filter (Standard)...................................................................................... 57
Figure 7-1 – Installation Of Coupling Cushions.................................................................................... 59
Summary of Contents for AUTO SENTRY EAU99G
