Generator Faults
12.8.20
Kapitel/Chapter 8: Generator Faults - Seite/Page 101
8. Generator Faults
8.1 Personal requirements
The work described here, unless otherwise indicated, are performed by the operator.
Any further repair work may be performed only by specially trained personnel or by authorized repair shops (Fischer
Panda service points). This is especially for working on the valve timing, fuel injection system and the engine repair.
8.2 Hazard notes for this chapter
Note!:
see “Safety first!” on Page 10.
Also consider the general safety instructions at the first
pages of this manual.
Warning!: Automatic start
Danger for life! - The generator can be equipped with a
automatic start device. This means the generator can be
started by an external signal. To avoid an unexpected
starting of the generator, the starter battery must be
disconnected before start working at the generator.
Warning!: Risk of injury
Working at a running generator can result in severe
personal injury. Therefore before starting work at the
generator:
Make sure that the generator is stopped and the starter
battery is disconnected to guarantee that the generator
cannot be inadvertently started.
Do not run the generator with removed sound isolation cover.
Warning!: Risk of injury
Improper installation/maintenance can result in severe
personal injuries or material damage.
• Always undertake installation/maintenance work when the
generator is switched off.
• Ensure there is sufficient installation clearance before start
working.
• Ensure tidiness and cleanliness at the workplace. Loose
components and tools lying around or on top of each other
are sources of accidents.
• Only perform installation work using commercially available
tools and special tools. incorrect or damaged tools can
result injuries.
Warning!: Danger of fire
Oil and fuel vapours can ignite on contact with ignition
sources. Therefore:
• No open flames during work on the generator.
• Do not smoke.
• Remove oil and fuel residues from the generator and floor.
