USE AND MAINTENANCE MANUAL - SECTION 3
STOCK PICKER ELEVAH 51 MOVE
– Rev. 08_2020
Page 3-4
During the moving phase (on the ground):
ü
Cautiously move the machine avoiding sudden manoeuvres;
ü
DO NOT TRANSPORT PERSONS on the base frame of the machine and in any other
position except for in the position inside the cage;
ü
Check the structural condition and cleanliness of the surfaces on which the machine is used
(verify the surface is suitable for the weight of the machine in work conditions).
During the ascent and descent phase:
ü
Observe the maximum admissible capacity weights in the cage;
ü
Ascertain overhead obstacles are not present along the trajectory, in vertical;
ü
Do not induce dangerous vibrations and/or oscillations such to entail stability loss of the machine
and cause an eventual overturning.
ATTENTION
THE STOCK PICKER IS PROVIDED WITH AN AUTOMATIC BASE LEVELLING VERIFICATION
SYSTEM. WHEN THE MACHINE EXCEEDS THE MAXIMUM SLOPE ALLOWED BY THE
MANUFACTURER (see the technical characteristics of the machine), IT EMITS A WARNING
SOUND. IN THESE CONDITIONS, WITH THE CAGE IN STAND-BY POSITION, THE MACHINE
CAN STILL MOVE WHEREAS, WITH THE CAGE LIFTED, EACH MOVEMENT IS PREVENTED
APART FROM CAGE DESCENT.
Prohibition signs:
Prohibition to overload the machine beyond the limits indicated
Prohibition to use the machine as an aerial platform to carry out works from heights
Prohibition to remove or tamper with the stability devices of the machine (sensors,
ballasts, etc.)
Prohibition to remove or tamper with the safety and protection devices of the machine
Prohibition to climb on or off the cage in places other than the provided gate
Prohibition to increase outreach or work height of the machine using additional
equipment (for example, ladders)
Prohibition to induce oscillations on the machine so as not to make it unstable
Prohibition to install any additional device that increases the wind load on the machine
(for example, warning signs)
Prohibition to come into contact with live electrical conductors
Prohibition to climb on/off the cage when elevated
Prohibition to lift/lower the cage without operator on board
