68
BRAKES
BRAKE FLUID
The brake fluid is:
-
harmful by inhalation, if swallowed or in
contact with skin, with possible serious con-
sequences;;
- irritating to skin;
-
harmful to the soil and aquatic environment,
harmful to flora and fauna.
To be avoided:
- contact with skin;
- inhalation of vapours;
- ingestion;
- release to the environment;
- exposure to air.
If swallowed do
NOT induce vomiting but seek
medical advice immediately (first aid post),
indicating the cause and how the accident oc-
curred.
After contact with skin, wash the affected part
immediately with soap and water, repeating the
operation until completely clean.
In case of contact with eyes or ears, rinse the
affected parts immediately with plenty of water
and seek medical advice immediately (first aid
post), indicating the cause and how the accident
occurred.
After contact with clothes, remove contaminated
articles and wash immediately with plenty of
water and soap. Change the dirty clothes, which
must be washed as soon as possible.
If brake fluid is accidentally spilt, clean the af-
fected area thoroughly.
Always wear latex gloves to protect hands when
carrying out maintenance.
Always close the brake fluid cover well after
every filling up.
KEEP OUT OF REACH OF CHILDREN. DISPOSE
OF THE BRAKE FLUID AT A SPECIAL WASTE
COLLECTION POINT.
The used brake fluid must be put in a sealed
container and taken to the nearest service sta-
tion or to a waste oil collection point where it
will be disposed of correctly.
DISK BRAKES
The brakes are a fundamental part for vehicle
safety. Always keep them fully efficient. Check
them for wear prior to setting off on any jour-
ney.
A decrease in braking power could be caused by
water depositing on the disks and on the brake
pads and it is therefore recommended that the
vehicle be dried thoroughly after washing. If trav-
elling on wet roads, proceed with caution and
continuously try out the brakes.
Also the salt used to melt snow and ice causes a
decrease in the efficiency of the braking system,
as does grease, oil and brake fluid; in this case it
is best to change the pads.
Whenever the pads are changed, take care for
the first 200 km when braking, as the pads do
not immediately adhere perfectly to the disk.
During this period it is preferable to brake early
and to apply the brake lever more forcefully,
while avoiding abrupt and prolonged braking so
as not to burn the pads and disks.
Do not use the vehicle if brake fluid is detected
leaking from the braking system.
The vehicle is fitted with disk brakes both at the
front and the rear, with separate hydraulic cir-
cuits.
Over a period of time the hydraulic system can
cause variations in the play of the brake levers or
an elastic resistance.
If you are unable to carry out the necessary con-
trols or doubt the safety of the vehicle, contact a
FANTIC MOTOR Dealer.
Also check that the braking system pipes are not
twisted, worn or present cracks, cuts or slits. Take
care that water or dust do not accidentally enter
the hydraulic system.
As the pads become worn the level of fluid in-
side the tanks decreases to automatically com-
pensate the wear.
FRONT BRAKE
Check that the brake fluid level is over the “MIN”
mark. Check the pads and disks for wear and if
they do not need replacing, proceed with top-
ping up.
FRONT BRAKE TOPPING UP
Using a Phillips screwdriver loosen the two
screws securing the brake fluid tank cover. Re-
Summary of Contents for Enduro 125
Page 1: ......
Page 43: ...84 NOTES...
