EV-97 Eurostar SL Microlight Maintenance Manual GEN/EUR/04 Issue 4
31
5.7.1 Aileron
Adjustment screws can be found on the aileron control stops located on the left and right of the
control stick base. These stops control the total deflection (up + down) of the aileron.
Each aileron’s neutral position can be adjusted using the adjustable end of the short rod inside the
cockpit. Alternatively the adjustable end of the long rod inside the wing can be used. Remove the
inspection cover for access.
The ailerons have greater upward than downward deflections. Aileron differential can be set using
the adjustable end of the rod connecting the bell crank inside the wing. Deflect the aileron upwards
for access.
5.7.2 Flap
The flap deflection is controlled by the positions of the slots in the flap lever gate in the cockpit.
The relative locations of these slots cannot be changed; however the flaps-up (and hence all other
positions) can be adjusted as follows:
•
Remove the baggage compartment floor which allows access to the rod connecting the flap
control lever to the torque tube arm.
•
Set the flap lever to the fully retracted position.
•
Adjust the rod end to set the flaps in their correct, retracted, position under the trailing edge.
The difference between the left and right flap deflections can also be adjusted by rotating the
eccentric pin locating in the inboard flap slot.
5.7.3 Elevator
Elevator stops are installed on the control stick as shown below.
