Empire Heating Systems DVC-35-1IP, Installation Instructions And Owner'S Manual

Page: 19 / 20

12430-3-0903 Page 19
Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through
the distributor. Parts can be shipped directly to the service person/dealer .
All parts listed in the Parts List have a Part Number. When ordering parts, first obtain the Model Number from the name plate on your
equipment. Then determine the Part Number (
not the Index Number) and the Description of each part from the following appropriate
illustration and list. Be sure to give all this information . . .
Furnace Model Number Part Description
Furnace Serial Number Part Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
Shipments contingent upon strikes, fires and all causes beyond our control.
HOW TO ORDER REPAIR PARTS
Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, IL 62222-0529
PARTS LIST
PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.
INDEX PART
NO. NUMBER DESCRIPTION
INDEX PART
NO. NUMBER DESCRIPTION
1 DV-1213 TOP PLATE
2 R-3165 DOOR CLIP (2 REQUIRED)
3 DV-1204 CASING SIDE - RIGHT
4 DV-1202 CASING BACK
5 DV-1205 CASING SIDE - LEFT
6 DV-1249 AIR DROP
7 DV-1230 TURBULATOR (3 REQUIRED)
8 DV-1233 OUTLET BOX REAR
9 DV-1224 OUTLET BOX COVER
10 R-3161 FAN BLADE
11 R-3166 FAN MOTOR
12 DV-1246 MOTOR MOUNTING BRACKET
13 8720130 BUSHING (4 REQUIRED)
14 8520141 RUBBER GROMMET
(4 REQUIRED)
15 8520142 BRASS BUSHING
(4 REQUIRED)
16 R-3164 DOOR CLIP (2 REQUIRED)
17 DV-1251 INNER SHIELD - RIGHT (INCLUDES
NO. 22)
18 R-6176 FAN CONTROL SWITCH
19 R-3175 LIMIT SWITCH
20 DV-1255 INNER SHIELD FRONT (USA)
20 15666 INNER FRONT ASSEMBLY
(CANADA)
21 DV-1253 INNER SHIELD COVER PLATE (2
REQUIRED)
22 DV-1252 INNER SHIELD -LEFT (INCLUDES
NO. 22)
23 DV-1257 EXCHANGER ASSEMBLY
24 R-3162 FILTER
25 R-3163 FILTER RETAINER
26 R-3232 PILOT - NAT (IP ONLY)
26 R-3233 PILOT - LPG (IP ONLY)
27 742126 ORIFICE - NAT (3 REQUIRED)
27 P-88-61 ORIFICE - LPG (3 REQUIRED)
28 DV-1236 MANIFOLD
29 DV-1259 FRONT PANEL
30 722040 MANIFOLD UNION
31 852051 BUSHING 3/8 X 1/2
32 R-3170 GAS VALVE - NAT (IP ONLY)
32 R-3171 GAS VALVE - LPG (IP ONLY)
32 R-2148 GAS VALVE - NAT (SPP ONLY)
32 R-5655 GAS VALVE - LPG (SPP ONLY)
33 R-2708 PIEZO IGNITOR (SPP ONLY)
34 DV-781 OBSERVATION HOLE COVER WITH MICA
35 712098 GASKET - OBS HOLE
36 FF-160 PIEZO BRACKET (SPP ONLY)
37 DV-1240 BURNER COMPARTMENT FRONT
38 DV-1265 BURNER COMPARTMENT BODY
39 712059 GASKET - TUBE SEAL
40 DV-775 SEAL BRACKET (SPP ONLY)
40 DV-691 SEAL BRACKET (IP ONLY)
41 712045 MANIFOLD GASKET
42 DV-1235 PILOT BRACKET (IP ONLY)
43 R-3031 BURNER (3 REQUIRED)
44 DV-1239 BURNER BRACKET
45 UH-810 TRANSFORMER MOUNTING BRACKET (SPP
ONLY)
45 UH-452 TRANSFORMER MOUNTING BRACKET (IP
ONLY)
46 R-1995 TRANSFORMER (SPP ONLY)
46 8720100 TRANSFORMER (IP ONLY)
47 UH-451 JUNCTION BOX COVER
48 DV-572 JUNCTION BOX
49 872056 BUSHING
50 872053 CORD SET
51 8720148 BUSHING
52 DV-1215 BOTTOM PLATE
53 R-3034 PILOT - NAT (SPP ONLY)
53 R-3035 PILOT - LPG (SPP ONLY)
54 GWT-021 PILOT BRACKET (SPP ONLY)
55 R-3180 ELECTRODE AND WIRE (SPP ONLY)
56 R-2256 THERMOCOUPLE -18" (SPP ONLY)
57 R-6389 WALL THERMOSTAT - 24 VOLT
58 DV-1273 VENT KIT COMPLETE
59 DV-1355 FLUE OUTLET TUBE
60 DV-1354 AIR INLET TUBE
61 DV-131 OUTSIDE MOUNTING PLATE
62 DV-769 VENT CAP
NOT SHOWN DV-1261 PILOT TUBING
NOT SHOWN 742158 PILOT ORIFICE - NAT (SPP ONLY)
NOT SHOWN 742266 PILOT ORIFICE - LPG (SPP ONLY)
NOT SHOWN 742154 PILOT ORIFICE - NAT (IP ONLY)
NOT SHOWN R-3265 PILOT ORIFICE - LPG (IP ONLY)
NOT SHOWN R-3172 WIRE HARNESS (SPP ONLY)
NOT SHOWN R-3173 WIRE HARNESS (IP ONLY)
NOT SHOWN R-3236 WIRE (IP ONLY)
USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.