![background image](http://html1.mh-extra.com/html/empire-comfort-systems/ol48tp10p-1/ol48tp10p-1_installation-instructions-and-owners-manual_2403955014.webp)
37795-3-0119
Page 14
FiRepiT inSTallaTiOn (cOnT'D)
•
Solid fuels shall not be burned in this firepit.
•
The maximum gas inlet supply pressure is 11 in. for Propane
and 7 in. for Natural.
•
For firepits with a fixed fuel piping system and equipped with
a gas pressure regulator, the required manifold pressure in
inches water column: 11 in. for Propane and
4.5 in. Natural.
•
For firepits with a fixed fuel piping system and equipped with
a firepit gas pressure regulator, the firepit and its individual
shutoff valve must be disconnected from the gas supply pip
-
ing system during any pressure testing of that system at test
pressures in excess of 1/2 psi (3.5 kPa).
The firepit must be isolated from the gas supply piping
system by closing its individual manual shutoff valve during
any pressure testing of the gas supply piping system at test
pressures equal to or less than 1/2 psi (3.5 kPa).
Check all local codes for requirements, especially for the size and
type of gas supply line required.
RecOMMenDeD MiniMUM GaS pipe DiaMeTeR
pipe
length
Schedule 40 pipe
inside Diameter
Tubing, Type l
Outside Diameter
natural propane natural
propane
0-10 feet
0-3 meters
1/2 in.
12.7mm
3/8 in.
9.5mm
1/2 in.
12.7mm
3/8 in.
9.5mm
10-40 feet
4-12 meters
1/2 in.
12.7mm
1/2 in.
12.7mm
5/8 in.
15.9mm
1/2 in.
12.7mm
40-100 feet
13-30 meters
1/2 in.
12.7mm
1/2 in.
12.7mm
3/4 in.
19mm
1/2 in.
12.7mm
100-150 feet
31-46 meters
3/4 in.
19mm
1/2 in.
12.7mm
7/8 in.
22.2mm
3/4 in.
19mm
NOTICE:
Check to confirm whether your local codes allow plastic
or copper tubing for outdoor use.
NOTICE:
Because some municipalities have additional local codes,
consult your local authority and installation code.
installing a Manual Gas Shut-Off Valve
Each firepit must have an accessible manual gas shut-off valve
located in the vicinity of the unit. Where none exists, or where its size
or location is not adequate, contact your local authorized installer
for installation or relocation.
Compounds used on threaded joints of gas piping shall be resistant
to the action of liquefied petroleum gases. The gas lines must be
checked for leaks by the installer. This should be done with a soap
solution watching for bubbles on all exposed connections, and if
unexposed, a pressure test should be made. To avoid damage to
the gas piping, remove all testing solution when testing is complete.
WaRninG
Never use an exposed flame to check for leaks. The firepit
must be disconnected from piping at inlet of control valve
and pipe capped or plugged for pressure test. never pressure
test with firepit connected; control valve will sustain damage!
A gas valve and ground joint union should be installed in the gas
line upstream of the gas control to aid in servicing. It is required by
the National Fuel Gas Code that a drip line be installed near the
gas inlet. This should consist of a vertical length of pipe connected
into the gas line by a tee fiting with a cap on the bottom in which
condensation and foreign particles may collect.
The use of the following gas connectors is recommended:
— ANSI Z21.24 Appliance Connectors of Corrugated Metal Tubing
and Fittings
— ANSI Z21.45 Assembled Flexible Appliance Connectors of
Other Than All-Metal Construction
The above connectors may be used if acceptable by the authority
having jurisdiction The Commonwealth of Massachusetts requires
that a flexible appliance connector cannot exceed three feet in length.
LP GAS
SUPPLY
SHUT-OFF
VALVE
FLEX TUBING
MALE NPT to
MALE FLARE
VALVE
MALE NPT to
MALE FLARE
LP GAS
SUPPLY
FEMALE NPT to
FEMALE NPT
LP GAS SUPPLY
NATURAL
GAS SUPPLY
SHUT-OFF
VALVE
FLEX TUBING
MALE NPT to
MALE FLARE
REGULATOR
NIPPLE
NATURAL
GAS SUPPLY
MALE NPT to
MALE FLARE
VALVE
FEMALE NPT to
FEMALE NPT
NAT GAS SUPPLY
Figure 18
NOTICE:
Gas shut-off valve shown. Other valves approved to
use with gas allowed.
Flex tubing to valve is pre-installed at the factory. Flare connector
is loosely installed for shipping purposes only. An accessible
manual gas shut-off valve must be installed external to the firepit.
GAS SUPPLY
PROPANE GAS SUPPLY
NATURAL GAS SUPPLY