29
Trouble shooting
Problem
Check
Status
Cause
Remedy
Engine
cranks,
start hard or
does
not start.
Fuel at
carburetor.
No fuel at
carburetor.
Fuel strainer
clogged.
Fuel line clogged.
Carburetor.
Clean or
replace.
Clean or
replace.
See local
dealer
Fuel at
cylinder.
No fuel at
cylinder.
Carburetor.
See local
dealer
Muffler wet
with
fuel.
Fuel mixture too
rich.
Open choke.
Clean or
replace
air filter.
Adjust
carburetor.
See local
dealer
Spark at end
of
plug wire.
No spark.
Stop switch off.
Electrical problem.
Interlock switch.
Turn switch to
On.
See address
on
the warranty
card.
See local
dealer
Spark at
plug.
No spark.
Spark gap
incorrect.
Covered with
carbon.
Fouled with fuel.
Plug defective.
Adjust to 0.65
mm (0".026).
Clean or
replace.
Clean or
replace.
Replace plug.
Engine
runs, but
dies or does
not
accelerate
properly.
Air filter.
Air filter dirty.
Normal wear.
Clean or
replace.
Fuel filter.
Fuel filter dirty
Contaminants or
residues in fuel.
Replace.
Fuel vent.
Fuel vent
plugged.
Contaminants or
residues in fuel.
Clean or
replace.
Spark plug.
Plug dirty or
worn.
Normal wear.
Clean and
adjust
or replace.
Carburetor.
Improper
adjustment.
Vibration
Adjust.
Cooling
system.
Cooling system
dirty or
plugged.
Extended
operation in dusty
or dirty locations.
Clean.
Engine
does not
crank
N/A
N/A
Internal engine
problem
See local
dealer
Warning! Fuel vapors are extremely flammable and may
cause fire and/or
explosion. Never test for ignition spark by grounding
spark plug near cylinder
plug hole, otherwise serious personal injury may result.
Storage
Warning! During operation the muffler and surrounding
cover become hot.
Always keep exhaust area clear of flammable debris
during transportation or when storing, otherwise serious
personal injury may result.
Long Term Storage (over 30 days)
Do not store your hedge trimmer for a prolonged period of time
(30 days or longer) without performing protective storage
maintenance which includes the following:
●
Store hedge trimmer in a dry, dust free place, out of the reach
of children.
Warning! Do not store in enclosure where fuel fumes
may accumulate or reach an open flame or spark,
otherwise serious personal injury may result.
●
Place the ignition switch in the “STOP” position.
●
Remove accumulation of grease, oil, dirt and debris from
exterior of hedge trimmer.
●
Perform all periodic lubrication and services that are required.
●
Apply clean oil to the entire length of the blade. Be certain the
blade bolts are
lubricated.
●
Install blade cover on blades.
●
Tighten all the screws and nuts.
●
Drain the fuel tank completely and pull the recoil starter handle
several times to
remove fuel from the carburetor.
●
Remove the spark plug and pour 7cc (1/4 oz.) of fresh, clean,
two-stroke engine oil
into the cylinder through the spark plug hole.
●
Place a clean cloth over the spark plug hole.
●
Pull the recoil starter handle 2-3 times to distribute the oil
inside the engine.
●
Observe the piston location through the spark plug hole. Pull
the recoil handle slowly
until the piston reaches the top of its travel and leave it there.
●
Install the spark plug (do not connect ignition cable).
Important:
Always store and transport hedge trimmers in a
stable, horizontal position.
Support gear case and cutting blades to prevent excessive
flexing, which may cause damage to these components. Always
install blade cover when transporting or storing hedge trimmer.
Environment
To prevent damage during transport, the appliance is delivered
in a solid packaging which consists largely of reusable material.
Therefore please make use of options for recycling the
packaging.
SERVICE
·
Only qualified specialist personnel and original replacement
parts should be used for
repairs. This will ensure that your device remains safe.
STORAGE
·
Thoroughly clean the whole machine and its accessories.
·
Store it out of the reach of children, in a stable and secure
position, in a cool and dry place, avoid too high and too low
temperatures.
·
Protect it from exposure to direct sunlight. Keep it in the dark, if
possible.
·
Don’t keep it in plastic bags to avoid humidity build-up.
