DCS BGB30-BQR Series, Use And Care Manual

Page: 5 / 80

3
IMPORTANT SAFETY NOTICE!
Certain Liquid Propane dealers may fill liquid propane cylinders for use in the grill beyond cylinder filling capacity.
This “Overfilling” may create a dangerous condition.
“Overfilled” tanks can build up excess pressure. As a safety device, the tank pressure relief valve will vent
propane gas vapor to relieve this excess pressure. This vapor is combustible and therefore can be ignited. To
reduce this danger, you should take the following safety precautions:
1. When you have your tank filled, be sure you tell the supplier to fill it to no more than 3/4 (75%) of its total
capacity.
2 . If you own or use a spare tank, or have a disconnected tank, you should NEVER
store it near or under the grill/cart unit or heat box, or near any other ignition or
heat source. A metallic sticker with this warning is provided with the grill to
remind you, your family and all others who may use your grill of these safety
precautions. Install this sticker close to your barbeque grill.
3. Do not store a full tank in direct sunlight.
WARNING!
Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS”
section of this manual. This grill is for outdoor use only.
WARNING!
Push and hold the igniter button, turn the selected burner knob to “HI”. If burner does
not light in 4 to 5 seconds turn knob “OFF” and wait 5 minutes before trying again for
any accumulated gas to dissipate.
■
Begin by insuring proper installation and
servicing. Follow the installation instructions
within this manual. Have your grill installed
by a qualified installer. Have the installer
show you where the gas supply shut-off valve
is located so that you know where and how to
shut off the gas to the grill. If you smell gas,
your installer has not done a proper job of
checking for leaks. If the connections are not
perfectly sealed, you can have a small leak
and therefore a faint gas smell. Finding a leak
is not a “do-it-yourself ” procedure. Some
leaks can only be found with the burner
control in the “ON” position and this must be
done by a qualified technician.
■
Children should not be left alone or unattended in an area where the grill is being used. Never allow them to sit,
stand or play on or around the grill at any time. When in use, portions of the grill get hot enough to cause
severe burns.
■
Do not store items of interest to children around or below the grill, in the cart or masonry enclosure. Never
allow children to crawl inside a cart or enclosure.
■
Never attach or disconnect an LP cylinder, or move or alter gas fittings when the grill is in operation or is hot.
■
Clean and perform general maintenance on the grill twice a year. Watch for corrosion, cracks, or insect activity.
Check the regulator, hoses, burner ports, air shutter, and venturi/valve section carefully. Always turn off gas at
the source (tank or supply line) prior to inspecting parts.
SAFETY PRACTICES & PRECAUTIONS
• Always follow lighting instructions.
• Lid must be opened before lighting
the grill.
• Check for gas leaks before lighting.
• Never lean over an open grill when
lighting. Serious burns may result.
• Hot surfaces surrounding grill
grates could cause serious burns.
• Always leave at least 12" clearance
to combustibles around the grill.
• Never store a spare LP cylinder
under or near this unit.
• Never fill the tank beyond 3/4 full. A
fire causing death or serious injury
may occur.
WARNING
STICKER