Cornelius SPIRIT, Installation Manual

Page: 36 / 41

31
317961000
Trouble Probable Cause Remedy
DISPENSED PRODUCT
PRODUCES FOAM AS IT
LEAVES DISPENSING VALVE.
(cont’d) E. Dispensing valve restricted or
dirty. E. Sanitize syrup system as
instructed.
F. Tapered nylon washer inside
carbonated water line swivel
nut connector distorted
restricting carbonated water
flow. F. Replace nylon washer. Make sure
it is properly seated.
G. Dirty water supply. G. Check water filter. Replace
cartridge. (see NOTE)
NOTE: If water supply is dirty, be sure to flush lines and carbonator completely. It may be necessary to
remove lines to carbonator tank, invert tank, and flush tank and all inlet lines to remove any foreign
particles or dirt.
NO PRODUCT DISPENSED
FROM ALL DISPENSING
VALVES A. Unit POWER SWITCH in
‘‘OFF’’ position. A. Place Unit POWER SWITCH in
‘‘ON’’ position.
B. No electrical power to Unit. B. Plug in Unit power cord.
C. Disconnected dispensing
valves power cord. C. Connect dispensing valves power
cord.
D. Disconnected or broken wiring
to dispensing valves. D. Connect or replace wiring.
E. Inoperative transformer. E. Replace transformer as
instructed.
NO PRODUCT DISPENSED
FROM ONE DISPENSING
VALVE. A. Broken or disconnected wiring. A. Repair or connect wiring.
B. Inoperative dispensing valve
solenoid coil. B. Replace solenoid coil as
instructed.
C. Inoperative dispensing valve
micro switch. C. Replace micro switch as
instructed.
ONLY CARBONATED WATER
DISPENSED. A. Quick disconnects not secure
on syrup tanks. A. Secure quick disconnects on
syrup tanks.
B. Out of syrup. B. Replenish syrup supply as
instructed.
C. Syrup tanks secondary CO
2
regulator not properly
adjusted.
C. Adjust syrup tanks secondary
CO
2
regulator as instructed.
D. Inoperable dispensing valve. D. Repair dispensing valve.
E. Dispensing valve syrup flow
regulator not properly
adjusted. E. Adjust dispensing valve syrup
flow regulator (Water-to-Syrup
‘‘Ratio’’) as instructed.
F. Dispensing valve syrup flow
regulator, syrup tank quick
disconnect, or syrup lines
restricted. F. Sanitize syrup system as
instructed.