![background image](http://html1.mh-extra.com/html/club-car/carryall-i-1997/carryall-i-1997_owners-manual_2626708040.webp)
34
Storage - Gasoline Vehicle, Continued:
6. Grease front suspension and do all quarterly periodic lubrication
(See Periodic Lubrication Sched-
ule, Page 43).
7. Thoroughly clean front body, rear body, seats, cargo bed, engine compartment, and underside of vehi-
cle.
8. Do not latch the park brake. Block tires to prevent the vehicle from rolling.
TO RETURN THE STORED VEHICLE TO SERVICE:
1. Restore fuel system to operation.
1.1. Remove plug from the fuel tank vent nipple and reconnect fuel vent line to tank.
1.2. Place the Forward and Reverse Lever in the NEUTRAL position and the neutral lock-out cam in
the SERVICE position. Crank the engine until fuel is pumped into the carburetor and fuel lines
and the engine starts. Turn the engine off and return the neutral lock-out cam to the OPERATE
position.
2. Readjust tire pressure
(See Tire Specifications, Page 45)
.
3. Perform the Pre-Operation Checklist
(See pages 15 and 16)
.
STORAGE - ELECTRIC VEHICLE
1. Unload the vehicle completely, so that only minimum vehicle weight will be on the tires.
2. Fully charge batteries
(See Batteries - Electric Vehicle, Page 48)
.
•
WHEN RUNNING THE ENGINE FOR THE FIRST TIME AFTER STORAGE, IT MAY SMOKE
EXCESSIVELY FOR A SHORT WHILE DUE TO THE OIL ADDED TO THE ENGINE IN PREPARA-
TION FOR STORAGE.
•
TURN THE KEY SWITCH OFF, REMOVE THE KEY, AND LEAVE THE FORWARD AND REVERSE
SWITCH IN THE NEUTRAL POSITION DURING STORAGE. THIS IS TO PREVENT UNINTEN-
TIONAL STARTING OF THE VEHICLE.
•
DO NOT ATTEMPT TO CHARGE FROZEN BATTERIES OR BATTERIES WITH BULGED CASES.
DISCARD THE BATTERY. FROZEN BATTERIES CAN EXPLODE.
•
BATTERIES IN LOW STATE OF CHARGE WILL FREEZE AT LOW TEMPERATURES.
•
WHEN WASHING THE VEHICLE, DO NOT DIRECT WATER STREAM AT THE SPEED SWITCH,
FORWARD AND REVERSE SWITCH, OR OTHER ELECTRONIC COMPONENT.
•
IF BATTERY WIRE TERMINALS ARE DAMAGED OR CORRODED, THEY SHOULD BE
REPLACED OR CLEANED AS NECESSARY. FAILURE TO DO SO MAY CAUSE THEM TO OVER-
HEAT DURING OPERATION.
NOTE
WARNING
CAUTION
Summary of Contents for CARRYALL I 1997
