Controls and Indicators
77
Figure 12
Accelerator and Brake Pedals
HEADLIGHT CONTROL
The headlight control (2) is located on the dash to the left of the key switch
(Figure 9)
. Pull out to turn the lights on,
push in to turn the lights off. The headlights operate on 12 volts DC from the battery.
See following NOTE.
NOTE:
Using the headlights for extended periods of time without the engine running, or with the engine idling, will
discharge the battery.
BATTERY WARNING LIGHT
Electric Vehicles Only
Electric vehicles feature a dash-mounted warning light (to the right of the key switch) that, when the vehicle is in
operation, indicates low battery voltage or, when the vehicle is being charged, indicates a charging problem. The
warning light is controlled by the onboard computer.
When the vehicle is in operation, the warning light will illuminate and remain illuminated if:
• Batteries’ voltage drops below 48 volts when there is no load on the batteries (the vehicle is stopped and there
are no accessories on).
• Batteries have discharged to less than 25% of rated capacity.
If the warning light illuminates when the vehicle is operating, there will be enough power remaining to drive the vehicle
for approximately 30 minutes. However, the vehicle should be charged at the first opportunity. If the warning light
illuminates and the vehicle is unable to operate for 30 minutes, have your Club Car distributor/dealer check the
vehicle for a possible battery or electrical system problem.
When the batteries receive an incomplete charge because 1) the DC power cord is disconnected, 2) AC power
to the charger is interrupted, 3) automatic charger shut-off occurs after 16 hours of operation, or 4) the charger
malfunctions, the warning light will indicate as follows:
• The warning light will not illuminate if the charge is 90% or more complete. The onboard computer will retain in
memory the amount of charge needed to fully replenish the batteries and will complete the charge during the
next charge cycle.
• When the charger is unplugged, the warning light will illuminate and remain illuminated for 10 seconds if the charge
is less than 90% complete but the vehicle has enough power for approximately 30 minutes of operation. This will
alert the operator that the vehicle may be used, but that it must be charged to completion as soon as possible.
Page 18
Carryall 100 CE Mark Owner’s Manual
