![background image](http://html1.mh-extra.com/html/club-car/2007-xrt-850/2007-xrt-850_owners-manual_2626830058.webp)
Battery Charger, QuiQ™ – Electric Vehicles
CHARGER OPERATING INSTRUCTIONS – QUIQ BATTERY CHARGERS
See General Warnings on page 10.
Charger Displays
10-LED display on charger:
LED Color
Indication
(following the
power-on self test)
Solid:
Displays approximate scale of current output during Bulk phase.
Ammeter
(Amber)
Flashing:
High internal charger temperature. Output reduced. Also
displays algorithm #1-6 for 11 seconds if no battery is connected.
Solid:
Bulk charge phase complete, 80% charged. In Absorption phase.
80% Charge
(Amber)
Flashing:
With no battery connected, indicates algorithm # selected by
number of flashes.
Solid:
Charging complete. Charger in Maintenance Mode.
100% Charge
(Green)
Flashing:
Absorption phase complete. In Finish phase.
Solid:
AC power good
AC On
(Amber)
Flashing:
Low AC Voltage. Check voltage and power cord length (see
above for guidelines).
Fault (Red)
Flashing:
Charger error. Reset charger power and refer to Troubleshooting
Instructions below.
AC Power Connection
CAUTION
• Charger can be hot during charging. Use hand protection if handling the charger while charging.
NOTE:
Make sure that the AC cord provided with your charger has the proper AC plug for your location. If it does not,
contact your Club Car representative to obtain the proper cord or plug.
Only use
ONE
charger on a single 15 amp circuit, or the circuit may become overloaded.
See QuiQ™ Battery
Charger Specifications on page 67.
To reduce the risk of electric shock, the battery charger must be grounded. The charger is equipped with an AC
electric cord with an equipment-grounding conductor and a grounding type plug. The AC plug must be connected to
an appropriate receptacle that is properly installed and grounded in accordance with the National Electric Code and
all local codes and ordinances.
The AC power cord must be a three-conductor, no. 12 AWG (American Wire Gauge) or no. 14 SWG (British Standard
Wire Gauge), heavy-duty cord with ground, properly wired and in good electrical condition. Keep it as short as
possible: no more than 12 feet (3.7 m). Place all cords so they will not be stepped on, tripped over, or otherwise
subject to damage or stress.
Charging Batteries
NOTE:
Batteries should be put on charge even if they have been used for only a short time, i.e., 10 minutes. The
charger is automatic and will turn off when batteries are fully charged. If the charger does not seem to be
operating properly, or if the batteries seem weak, contact a local Club Car distributor/dealer.
Page 56
XRT 850 Electric and Gasoline Vehicle Owner’s Manual
Summary of Contents for 2007 XRT 850
Page 2: ......
Page 6: ...Warranties 70 Page 4 XRT 850 Electric and Gasoline Vehicle Owner s Manual...
Page 79: ......