Club Car 2002 Pioneer 1200, Owner'S Manual

Page: 32 / 44

Fueling Instructions
Page 30 2002 Pioneer 1200 Gasoline Vehicle Owner’s Manual
FUELING INSTRUCTIONS
Read DANGER and WARNING on page 7.
∆
DANGER
• Turn key switch to OFF before fueling.
• Never pour gasoline into the fuel tank when the engine is hot or while it is running.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be
grounded. If the pump is not grounded, the vehicle must be grounded to the pump before and
during the fueling operation.
• If the vehicle has an all-weather enclosure installed, be sure the gas tank is properly vented as
shown (Figure 19, Page 30).
• To avoid the possibility of fire, clean up any spilled gasoline before operating the vehicle.
∆
CAUTION
• To allow for expansion, do not fill higher than one inch (2.54 cm) from the top of the fuel tank.
Avoid spilling fuel.
NOTE: Whenever possible, avoid using oxygenated fuels and fuels that are blended with alcohol. Vehicles
to be stored for extended periods should be prepared for storage as instructed on page 22 of this
manual.
1. Remove the passenger seat.
2. Remove fuel cap and fill tank with fresh unleaded gasoline only. See preceding DANGER, CAUTION,
and NOTE.
3. Replace fuel cap on tank. Make sure cap is tightened securely.
4. Replace passenger seat.
∆
WARNING
• Make sure seat hinges and latch are securely engaged before operating vehicle.
Figure 19 Fuel Tank
TO CARBURETOR
VENT TUBE
VENT
GAS
TANK
FUEL
SHUT-OFF
VALVE