Club Car 2002 Pioneer 1200, Owner'S Manual

Page: 30 / 44

Master Cylinder
Page 28 2002 Pioneer 1200 Gasoline Vehicle Owner’s Manual
MASTER CYLINDER
The master cylinder is located under the passenger seat toward the center of the vehicle (Figure 16,
Page 28) . Raise or remove the seat to check the brake fluid level.
When checking the brake fluid, also inspect the following:
• The presence of brake fluid on the exterior surface of the master cylinder indicates a leak.
• The vent holes in the reservoir cover should be clean and open.
• The reservoir diaphragm should not have holes or other damage.
BRAKE FLUID
Brake fluid level should be within 1/4 inch (6 mm) from top of reservoir (Figure 16, Page 28) . Also, brake fluid
should be clean with no residue in bottom of reservoir or other evidence of contamination.
∆
CAUTION
• Use only DOT-5 (silicone) Brake Fluid. Use of any other type brake fluid is not recommended.
ENGINE OIL
Even though the oil warning light on the dash should illuminate if oil is getting low, the engine oil level should
be checked monthly. The vehicle should be on a level surface when checking oil. Do not overfill with oil.
1. Remove the oil level dipstick from the oil filler tube and wipe oil from stick (Figure 17, Page 29) . See fol-
lowing CAUTION.
∆
CAUTION
• Do not remove dipstick while engine is running.
2. Check oil by fully inserting the dipstick into the oil filler tube and immediately remove it again.
• If the oil level is at or below the low level mark on the dipstick gauge, add oil until the level is between
low and full levels (safe level).
Figure 16 Brake Fluid Reservoir
WARNING
USE ONL
Y
DOT 3 FLUID
FROM A
SEALED CONT
AINER
MA
X
MIN
R
E
N
I
A
T
N
O
C
D
E L
A E S A
M O
R
F
D I
U
L
F
3
.
T
.
O
.
D
Y L N
O E
S U
CLEAN F
IL
L
E
R
C
A
P
S
BE
FO
RE
RE
M
O
V
I
N
G
MIN
MAX
Full
Level
Low
Level
Safe Level