Clarke ZE, Operation And Maintenance Instruction Manual, Page: 35 / 41

Page 35 of 41

Fuel Tank

General Inspection

Governor Run-Stop Control

Jacket Water Heater

Lubrication Oil Level

Operating Gauges

Remove Water from Fuel Filter

Run Engine

Warning Light
 Cooling Water Strainers
 Clean Radiator Core Debris (if equipped)
EVERY 6 MONTHS
 Batteries

Battery Charging Alternator

Belt tension

Coolant Protection Level

Driveshaft U-Joints

Fuel Lines
EVERY 1 YEAR
 Air Cleaner
 Fuel Priming Pump Strainer

Coolant Inhibitor

Crankcase Vent System
o
Driveshaft U-Joints
 Fuel & Oil Filters

Heat Exchanger Electrode
 Lubricating Oil

Mounting Isolators

Wiring System
EVERY 2 YEARS

Air Cleaner

Batteries

Belts

Coolant Hoses

Coolant
 Thermostat
 Remove Water Pump to Inspect Impeller and
Seal
IMPORTANT: Set main pump controller to “OFF”
while servicing engine. Before turning the main
pump controller to the "OFF" position, check with
the maintenance and security supervisors to verify
that all the departments concerned will be alerted of
the temporary interruption of their fire protection
equipment for normal maintenance or testing. Also,
alert the local fire department in the event that the
main pump controller is connected by silent alarm to
headquarters. When servicing is complete, return
main pump controller selector to "Automatic"
position and the mode selector on the engine to
“Automatic” position. Advise the appropriate
personnel the engine has been returned to the
“Automatic”.
5.0 TROUBLE SHOOTING
Consult Clarke Service Dealer or Factory. Service
dealers can be located by going to our website:
www.clarkefire.com . For trouble shooting pertaining
to the flashing of the "OVERSPEED SHUTDOWN"
lamp, see section 3.5.5.
6.0 PARTS INFORMATION
6.1 SPARE PARTS
To ensure best operation and efficiency of all engine
components, always use genuine Clarke spare parts.
Orders should specify:

Engine Model Number - See Engine General

Engine Serial Number - Specification

Part Number(s) Refer to Engine Maintenance
Parts List section 6.2 or Parts Illustration (see
Page 5).
Contact numbers for spare parts:
• www.clarkefire.com
• Phone USA: (513) 771-2200 Ext. 427 (calling
within USA)
• Phone UK: (44) 1236 429946 (calling outside USA)
• Fax USA: (513) 771-5375 (calling within USA)
• Fax UK: (44) 1236 427274 (calling outside USA)
• E-Mail USA:
parts@clarkefire.com
• E-Mail UK: dmurray@clarkefire.com
6.2
ENGINE MAINTENANCE PARTS LIST
Refer to Appendix “A” at the end of this manual.
ENGINE MODEL
Air Filter Service
Kit
Air Filter Oil
All 99-55050 C121157
Figure #39
7.0 OWNER ASSISTANCE
Consult Clarke Service Dealer or Factory. Service
Dealers can be located by going to our website:
www.clarkefire.com.
8.0 WARRANTY
8.1 GENERAL WARRANTY STATEMENT
The satisfactory performance of Clarke engines and
the goodwill of owners / operators of Clarke engines
are of primary concern to the Engine Manufacturer,