5
GENERAL SAFETY CONSIDERATIONS:
Operating this machine requires workers to perform work behind the trailer, it is critical to perform the
work safely. Communication between the tow vehicle driver and worker is critical. Worker and tow
vehicle driver must stay in communication, use an audible device or visual signals to communicate. A
worker must never ride on the trailer or position him or herself between the tow vehicle and trailer
when the tow vehicle is running. Tow vehicle driver must always be aware of workers position.
Only use a tow vehicle that is equipped with an electronic brake control system and has the
appropriate towing capacity
.
The best means for determining the vehicle's towing capacity is to read
the vehicle owner's manual. The owner's manual will provide detailed instructions and limitations,
usually accompanied by tips for safe towing. If the owner's manual has been misplaced, most
manufacturers provide free downloadable copies on their website.
T
owing with an undersized tow
vehicle
can cause the trailer to tow improperly, potentially causing loss of control. Overloading can
also cause unintended failures to tow vehicle.
The weight of your trailer
listed in this manual is for the base model without any additional
accessories or the weight of the sealant material. The weight of your trailer will vary, weigh your
machine to determining your Gross Vehicle Weight (GVW). Scales are sometimes available to use at
state highway weigh stations, refuse transfer stations and commercial truck stops.
TRAILER STABILIZATION PROCEDURE:
Going under the trailer puts a person at risk of severe injury or
death. Follow the procedure below to stabilize trailer before going
under the trailer.
METHOD #1 HITCH TO VEHICLE:
Park both the tow vehicle and trailer on a flat level surface. Place tow vehicle in park and remove
keys.
METHOD #2 UNHITCHED:
Park trailer on a level surface. Place wheel blocks in front of and behind wheels on both sides of the
trailer. Inspect your swivel jack thoroughly for damage or abnormal wear, especially if it was subjected
to abnormal load or shock. [
If damaged do not use, replace swivel jack
.] Turn the swivel jack to the
vertical position and pin in place. Use the swivel jack to decouple trailer from tow vehicle. After
raising the hitch coupler, crib, block, or otherwise secure the trailer at once.
Trailer Safety
WARNING
BREATHING DIESEL ENGINE EXHAUST EXPOSES YOU TO CHEMICALS KNOWN TO THE
STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUC-
TIVE HARM. ALWAYS START AND OPERATE THE ENGINE IN A WELL-VENTILATED AREA. IF
IN AN ENCLOSED AREA, VENT THE EXHAUST TO THE OUTSIDE. DO NOT MODIFY OR TAM-
PER WITH THE EXHAUST SYSTEM. DO NOT IDLE THE ENGINE EXCEPT AS NECESSARY.
FOR MORE INFORMATION GO TO;
WWW.P65WARNINGS.CA.GOV/DIESEL.
WARNING
