Char-Broil 463666114, Product Manual

Page: 6 / 44

6
Match-Lighting
• Do not lean over grill while lighting.
3. Open lid during lighting.
5. Push in and turn far knob to the HIGH position. Be
sure burner lights and stays lit.
6. Light other burner by pushing knob in and turning to the
HIGH position.
If ignition does NOT occur in 5 seconds, turn the
burner controls OFF, wait 5 minutes and repeat
the lighting procedure. If the burner does not ignite
with the valve open, gas will continue to flow out of
the burner and could accidently ignite with risk of
injury.
Turn controls and gas source or tank OFF
when not in use.
4. Place match into match holder (hanging from side panel
of grill). Light match; then light burner by placing match
through the match light hole on side of grill.
Ignitor Lighting
• Do not lean over grill while lighting.
1. Turn OFF gas burner control valves.
2. Turn ON gas at LP cylinder.
3. Open lid during lighting.
4.
To ignite, push and turn IGNITION BURNER knob to
HIGH .
5. Immediately, push IGNITOR button rapidly.
6. If ignition does NOT occur in 5 seconds, turn the burner
controls
OFF , wait 5 minutes and repeat the lighting
procedure. If ignitor does not work, follow match lighting
instructions.
7. To ignite remaining burner, turn knob to the HIGH
position starting with the burners closest to IGNITION
BURNER first.
CAUTION
WARNING
2. Turn ON gas at LP cylinder.
1. Turn OFF gas burner control valves.
8. Once all burners have ignited, turn control knobs to
desired setting.
WARNING
For Safe Use of Your Grill and to Avoid
Serious Injury:
• Do not let children operate or play near grill.
• Keep grill area clear and free from materials that burn.
• Do not block holes in sides or back of grill.
• Check burner flames regularly.
• Do not use charcoal or ceramic briquets in a gas grill.
• Use grill only in well-ventilated space. NEVER use in
enclosed space such as carport, garage, porch,
covered patio, or under an overhead structure of any
kind.
• Do not cover grates with aluminum foil or any other
material. This will block burner ventilation and
create a potentially dangerous condition resulting
in property damage and/or personal injury.
• Use grill at least 3 ft. from any wall or surface.
Maintain 10 ft. clearance to objects that can catch
fire or sources of ignition such as pilot lights on water
heaters, live electrical appliances, etc.
• Apartment Dwellers:
Check with management to learn the requirements
and fire codes for using an LP gas grill in your
apartment complex. If allowed, use outside on the
ground floor with a three (3) foot clearance from
walls or rails. Do not use on or under balconies.
• NEVER attempt to light burner with lid
closed. A buildup of non-ignited gas
inside a closed grill is hazardous.
• Never operate grill with LP cylinder out of
correct position specified in assembly
instructions.
• Always close LP cylinder valve and remove
coupling nut before moving LP cylinder from
specified operation position.
• If you notice grease or other hot material dripping from
grill onto valve, hose or regulator, turn off gas supply
at once. Determine the cause, correct it, then clean
and inspect valve, hose and regulator before
continuing. Perform a leak test.
• Keep ventilation openings in cylinder enclosure (grill
cart) free and clear of debris.
• Do not store objects or materials inside the grill cart
enclosure that would block the flow of combustion air
to the underside of either the control panel or the
firebox bowl.
• The regulator may make a humming or whistling noise
during operation. This will not affect safety or use of
grill.
• If you have a grill problem see the "Troubleshooting”
Section.
• If the regulator frosts, turn off grill and LP cylinder
valve immediately. This indicates a problem with the
cylinder and it should not be used on any product.
Return to supplier!
3 ft.
3 ft.
Leak Testing Valves, Hose and Regulator
1.Turn all grill control knobs to OFF.
2.
Be sure regulator is tightly connected to LP cylinder.
3. Completely open LP cylinder valve by turning hand
wheel counterclockwise. If you hear a rushing sound ,
turn gas off immediately. There is a major leak at the
connection.
Correct before proceeding .
4. Brush soapy solution onto areas circled below, or other
similar fittings on your grill.
5.If “growing” bubbles appear, there is a leak. Close
LP cylinder valve immediately and retighten
connections.
If leaks cannot be stopped do not try
to repair. Call for replacement parts.
6. Always close LP cylinder valve after performing leak
test by turning hand wheel clockwise.
NOTE: Sideburner
shelf fascia and other
parts not shown for
clarity.
• Outdoor gas appliance is not intended to be installed
in or on a boat.
• Outdoor gas appliance is not intended to be installed
in or on an RV.
• Never attempt to attach this grill to the self-contained
LP gas system of a camper trailer or motor home.
NOTE: Your grill
may NOT be
equipped with a
sideburner.
WARNING
Safety Tips
• Before opening LP cylinder valve, check the coupling
nut for tightness.
• When grill is not in use, turn off all control knobs and LP
cylinder valve.
• Never move grill while in operation or still hot.
• Some surfaces will be hot during use. Use long-
handled barbecue utensils and oven mitts to avoid
burns and splatters.
• Maximum load for sideburner and side shelf is 10 lbs.
• The grease tray or cup must be installed during use and
emptied after each use. Do not remove grease tray or
cup until grill has completely cooled.
• Clean grill often, preferably after each cookout. If a
bristle brush is used to clean any of the grill cooking
surfaces, ensure no loose bristles remain on cooking
surfaces prior to grilling. It is not recommended to clean
cooking surfaces while grill is hot.
• Do not use grill until leak-tested.
• If a leak is detected at any time, STOP!
• If you cannot stop a gas leak by closing the LP cylinder
valve leave area and call your fire department!
WARNING