Champion 73552i, Owner'S Manual And Operating Instructions

Page: 30 / 31

Troubleshooting
26 Rev 73552i-20100621 E
Troubleshooting
Problem Cause Solution
Generator will not start No fuel Add fuel
Faulty spark plug Replace spark plug
Unit loaded during start up Remove load from unit
Generator will not start;
Generator starts but runs roughly
Low oil level Fill crankcase to the proper level
Place generator on a flat, level surface
Choke in the wrong position. Adjust choke.
Spark plug wire loose Attach wire to spark plug
Generator shuts down during
operation
Out of fuel Fill fuel tank
Low oil level Fill crankcase to the proper level.
Place generator on a flat, level surface
Generator cannot supply enough
power or overheating
Generator is overloaded Review load and adjust. See “Power
Management”
Insufficient ventilation Check for air restriction. Move to a
well ventilated area
No AC output Cable not properly connected Check all connections
Connected device is defective Replace defective device
Circuit breaker is open Unplug electrical loads. Turn off
generator. Restart.
Faulty inverter assembly Replace
Loose wiring Inspect and tighten wiring
connections
Other Contact the help line.
Engine governor defective Contact the help line
Repeated circuit breaker tripping Faulty cords or device Check for damaged, bare or frayed
wires. Replace defective device