| 24 |
REV202207071617
Product Documentation web page for a complete list of settings specific for the inverter that you are pairing
with:
https://simpliphipower.com/product-documentation/
Table 5.0 – Operation Parameters
Recommended Operating Conditions for 10 Year Warranty
Depth of Discharge (DoD)
80% (~10,000 cycles)
90% (~5,000 cycles) 100% (~3,500 cycles)
Operating Temperature °F (°C)
32 to 120 (0 to 49)
Low Battery Cut-Off Voltage (V)
3
50.2
49.6
48
Absorb / High Cut-Off Voltage (V)
56
Absorb Time
0.5 Hours
Absorb End Amps (if applicable)
2% of the PHI Battery bank’s total Ah capacity
Table 5.1 – Operating Limitations
Notes / Operating Limitations for PHI Batteries
SimpliPHI 4.9
Limitations by Model
48V
Continuous Discharge Rate (ADC)
48.5
Surge Discharge Rate (ADC) – 10 minutes maximum
100
Continuous Charge Rate (ADC)
48.5
•
Levels are typically @ 25°C and may need adjusting at temperature extremes.
•
When performing rapid deep charge/discharge cycles, the PHI Battery should be allowed to "rest" 15
mins in between.
CAUTION
: When commissioning the system, the appropriate controller and inverter settings
must be programmed per the manufacturer’s recommendations. Consult the manufacturer’s
manuals and/or the Integration Guides listed on
SimpliPhi’s Product Documentation web page
Failing to do so will damage the SimpliPHI batteries and will Violate the terms of the Warranty.
6.0 – Troubleshooting
Certain SimpliPHI BMS fault trip conditions (outlined in Section 1.3.1 and Table 1.0 of this Manual) result in the
need for a manual re-set of your SimpliPHI Battery’s internal BMS. If a fault has occurred, consult SimpliPhi
Technical Support ([email protected]) to ensure that your SimpliPHI Battery bank has been sized correctly
and inhabits operational conditions.
Once the fault’s cause has been addressed with Support, take the following steps to re-set the BMS:
The PHI batteries are reading extremely low or no voltage:
1.
If the breakers are not all off already, turn off each of the built-in breakers in all of the SimpliPHI
Batteries in the battery bank.
