SECTION
4
Engine Does Not Crank
YES
NO
YES
NO
Is the battery fully charged
(12.6 volts or higher)?
Install new battery. Note: Check to see
that alternator is charging properly and
cables are clean and undamaged.
Is the battery connected?
Reconnect batterty.
YES
NO
When you turn the key to the RUN
position do you hear the fuel pump run?
YES
NO
Is the main circuit breaker
(30 Amp) popped?
Push circuit breaker in. Note: If circuit
breaker continues to trip you have an
electrical problem. Have machine serviced
by an authorized
BLUE
LINE service center.
With an electrical meter do you have at
least 12.6 volts or higher at the ignition
switch (BAT +) terminal?
Is the wire to the starter undamaged
and tightly connected to the starter?
Replace fuel pump and filter.
YES
NO
Disconnect the wire from the starter. With an
electrical meter do you have 12.6 volts or
higher when the ignition switch is turned
to the start position?
YES
NO
Replace ignition switch.
Repair or replace wire from starter/battery terminal
on the starter to the (BAT +) on the Ignition Switch.
YES
NO
Repair or replace wire from the (ST) terminal
on the Ignition Switch to the starter.
Remove the blower belts.
Does the engine start?
YES
NO
See Blower/Vacuum.
Replace starter.
Note: Make sure the engine has oil, waste recovery tank is empty,
and you have at least a half tank of gasoline.
BLUELINE HAZINATOR
®
27
