Blodgett 40GS-KLS Series, Installation Operation & Maintenance

Page: 3 / 32

OM-40GS-KLS 1
IMPORTANT - READ FIRST - IMPORTANT
WARNING: FAILURE TO DISCONNECT POWER BEFORE SERvICING COULD RESULT IN ELECTROCUTION AND
DEATH.
WARNING: THIS UNIT IS INTENDED FOR USE IN THE COMMERCIAL HEATING, COOKING AND HOLDING OF
WATER AND FOOD PRODUCTS, PER THE INSTRUCTIONS CONTAINED IN THIS MANUAL. ANY
OTHER USE COULD RESULT IN SERIOUS PERSONAL INjURY OR DAMAGE TO THE EqUIPMENT
AND WILL vOID WARRANTY.
WARNING: IMPROPER INSTALLATION, ADjUSTMENT, ALTERATION, SERvICE OR MAINTENANCE CAN
CAUSE PROPERTY DAMAGE, INjURY OR DEATH. READ THE INSTALLATION, OPERATING AND
MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERvICING THIS
EqUIPMENT.
WARNING: THE UNIT MUST BE INSTALLED BY PERSONNEL qUALIFIED TO WORK WITH GAS, ELECTRICITY
AND PLUMBING. UNIT MUST BE INSTALLED IN ACCORDANCE WITH ALL APPLICABLE CODES.
CAUTION: TO AvOID DAMAGING PARTS OF THE BURNER SYSTEM UNDERNEATH THE KETTLE, LIFT THE
UNIT ONLY BY THE RING BENEATH THE OUTER PORTION OF THE BODY.
WARNING: DO NOT ATTACH THE UNIT TO A TYPE “B” vENT. IT COULD CAUSE FIRE OR PROPERTY DAMAGE.
WARNING: DO NOT CONNECT ANY PIPING TO THE PRESSURE RELIEF vALvE. IT MUST BE FREE TO vENT TO
vENT STEAM AS NEEDED. TO AvOID BURNS FROM THE vENTED STEAM THE vALvE DISCHARGE
SHOULD POINT DOWN. IMPROPER INSTALLATION WILL vOID WARRANTY.
DANGER: ELECTRICALLY GROUND THE UNIT AT THE TERMINAL PROvIDED. FAILURE TO GROUND THE
UNIT COULD RESULT IN ELECTROCUTION AND DEATH.
CAUTION: BE SURE ALL OPERATORS READ, UNDERSTAND AND FOLLOW THE OPERATING INSTRUCTIONS,
CAUTIONS AND SAFETY INSTRUCTIONS CONTAINED IN THIS MANUAL.
CAUTION: DO NOT OvERFILL THE KETTLE WHEN COOKING, HOLDING OR CLEANING. KEEP LIqUIDS
A MINIMUM OF 2-3” (5-8 CM) BELOW THE KETTLE BODY RIM TO ALLOW CLEARANCE FOR
STIRRING, BOILING AND SAFE TRANSFER OF PRODUCT.
CAUTION: KEEP FLOORS IN FRONT OF KETTLE WORK AREA CLEAN AND DRY. IF SPILLS OCCUR, CLEAN
IMMEDIATELY TO AvOID SLIPS OR FALLS.
WARNING: KEEP WATER AND SOLUTIONS OUT OF CONTROLS AND BURNERS. NEvER USE A HIGH
PRESSURE HOSE TO CLEAn THE KETTLE SURFACES.
CAUTION: MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS MEMBRANES AND CLOTHING.
TAKE PRECAUTIONS: WEAR RUBBER GLOvES, GOGGLES OR FACE SHIELD AND PROTECTIvE
CLOTHING. CAREFULLY READ WARNINGS AND FOLLOW DIRECTIONS ON CLEANER LABELS.
IMPORTANT: DO NOT MIX PARTS OF DIFFERENT DRAW-OFF vALvES DURING WASHING. PARTS ARE NOT
INTERCHANGEABLE.
NOTICE: NEvER LEAvE A SANITIzER IN CONTACT WITH STAINLESS STEEL SURFACES LONGER THAN 10
MINUTES. LONGER CONTACT CAN CAUSE CORROSION.