Arctic Cat Jaguar Z1, Operator'S Manual

Page: 29 / 56

MAINTENANCE 25
9. Install the new oil filter by turn-
ing the oil filter by hand until
the seal has contacted the oil fil-
ter mounting surface; then
tighten the oil filter to 2.1 kg-m
(15 ft-lb).
10. Pour 2.9 l (3 U.S. qt) of the rec-
ommended engine oil into the
oil reservoir.
11. Open the air bleed bolt located
on the oil pump (beneath the
coolant tank) to purge air from
the oil hose.
ZJ004A
„
NOTE: When air can no longer
be heard purging from oil pump
bleed, tighten the bleed bolt to
1.05 kg-m (7.5 ft-lb).
12. Without starting the engine,
place the handlebar emergency
stop switch to the RUN position
and the ignition switch to the
ON position. The Oil Pressure
Warning Light should illumi-
nate.
„
NOTE: If the warning light does
not illuminate, take the snowmo-
bile to an authorized Arctic Cat
Snowmobile dealer for service.
13. If the warning light illuminates
(from step 12), start the engine.
The warning light should go out
within five seconds. If it does,
proceed to step 14.
„
NOTE: If the warning light does
not go out, shut the engine off
immediately and repeat step 11;
then place the ignition switch to
the ON position and repeat step
13. If the warning light does not
go out, take the snowmobile to
an authorized Arctic Cat Snow-
mobile dealer for service.
14. Shut the engine off and pour the
remaining amount (0.9 l or 1
U.S. qt) of recommended oil
into the oil reservoir; then pro-
ceed to Checking Engine Oil
Level sub-section to verify and
finalize the procedure.
SPARK PLUGS
„
NOTE: If spark plugs must be
replaced, take the snowmobile to
an authorized Arctic Cat Snow-
mobile dealer for inspection and
service. If not under warranty,
this service is at the discretion
and expense of the snowmobile
owner.
CHARGING BATTERY
! CAUTION
This maintenance-free battery
requires periodic charging to
prevent sulfiding. If the snow-
mobile will be idle for extended
periods of time, either run the
engine or trickle charge from
time to time. If the battery com-
pletely discharges, permanent
damage will occur requiring
replacement.
! WARNING
Always wear safety glasses
when connecting or disconnect-
ing a battery charger. Do not
smoke or allow open flames
near a charging battery.