Arctic Cat Jaguar Z1, Operator'S Manual

Page: 26 / 56

22 MAINTENANCE
REAR SUSPENSION (Every 40
Operating Hours)
„
NOTE: Arctic Cat recommends
that Arctic Cat Low-Temp Grease
(p/n 0636-593) be used for this
procedure.
1. Shut engine off and wait for all
moving parts to stop.
2. With the gas tank nearly empty
(less than 1/4 full), lay the
snowmobile on its left side. A
piece of cardboard should be
used to protect the finish on the
hood and belly pan.
3. Remove ice and snow buildup
from the skid frame to expose
the grease fittings.
0741-376
4. Lubricate the grease fittings
with low-temperature grease.
MAINTENANCE
PERIODIC MAINTENANCE CHECKLIST
ITEM INTERVAL REFER TO REMARKS
Brake System Daily Page 27 Check for binding, leakage, and proper operation; lever
firmness, travel, caliper, disc, and pads
Cooling System Daily Page 10 Check for leakage, damage, obstructions, coolant level
Oil System Daily Page 23-24 Check for leakage, damage, and engine oil level
Engine Oil 2000 miles/
Seasonal
Page 24 Change oil and filter
Battery Daily Page 10
Page 25 Check for proper charge and tight connections
Stop Switch Daily — Check for proper operation
Hoses Daily — Check for damage, leakage, and routing
Headlight & Taillight/Brakelight Daily Page 36 Check for proper operation and cleanliness
Steering System Daily — Check for proper operation, tightness of bolts, and
binding
Throttle Control System Daily Page 18 Check for binding, sticking, proper operation, throttle
cable tension, and routing
Drive Belt Daily
Monthly
Page 30 Check for wear, cracks, and fraying
Check length and width dimensions
Ski Wear Bars Daily Page 38 Check for wear and damage
Electrical Wiring Weekly — Check for wear, damage, tight connections, and routing
Exhaust System Weekly Page 9 Check for damage, leakage, and obstructions
Nuts, Bolts, Fasteners Weekly — Check tightness
Shock Absorbers Weekly Page 11 Check for fluid leakage and damage
Suspension Weekly Page 35 Check for damage, loose components, and proper
adjustment
Track Tension/Alignment Weekly Page 32
Page 33 Check/adjust as necessary
Wear Strips Weekly Page 39 Check for wear and damage
Wires & Cables Weekly — Check for wear, damage, and routing
Fuel System - Tank, Pump,
& Vent Hose
Weekly — Check for damage, wear, obstructions, and leakage
ACT Drive Gear Case Seasonal Page 20 Change drive fluid prior to storage
Heat Exchangers Monthly — Check for wear, leakage, and damage
Drive Clutch/Driven Pulley Monthly Page 10-11 Check for damage, abnormal noise, vibration,binding,
and sticking and clean off drive belt deposits
Front & Rear Suspension Monthly Page 21-22 Grease