© 2008 Aqua-Hot
®
600-D Hydronic Heating System Installation Manual
— Page 18 —
section 3: thermostats
Fresh Water Tank Thermostat Location:
Select a location that will ensure even-heat distribution
throughout the fresh water storage tank bay com-
partment in order to prevent the domestic water and
plumbing system from freezing.
Typically, only the bulb of the thermostat needs to be
physically mounted in the area requiring heat (usually in
close proximity to the domestic water pump). Refer-
ence Figure 26.
Do not mount the thermostat bulb in a drafty area.
The selected mounting location should allow for easy
operator access. Reference Figure 26.
Avoid mounting the fresh water tank thermostat’s bulb
too close to the bay heat exchanger.
Fresh Water Tank Thermostat Mounting:
1.
Determine a location for the thermostat based upon
the previous location information.
2.
Once the thermostat has been completely wired,
permanently mount the thermostat in place. Reference
Figure 26.
6
0 1 0
2 0
3 0
0
0
F
Bulb
Mounting
Tabs
Black Wire
(Connect to heating zone #3
“THERMO O” on the electronic
controller.)
Blue Wire
(Connect to heating zone #3
“THERM I” on the electronic controller.)
Figure 26
Fresh Water Tank Thermostat Wiring:
1.
Run two 18-gauge wires from the thermostat’s mount-
ing location to the Aqua-Hot’s electronic controller.
NOTE:
It is recommended that the wire numbers in Appendix
A be used when installing the Aqua-Hot in order to
assist with differentiating between the separate heating
zones and to aid service personnel with troubleshoot-
ing.
2.
Insert each thermostat wire into the appropriate termi-
nal/heating zone location in the electronic controller.
Reference Appendix A and Figure 27.
3.
Connect both wires to the appropriate leads of the
thermostat. Reference Figure 26.
Summary of Contents for 600-D
