F
G
Shower
Base
Tile
Adhesive
Waterproof
Drywall
Tile
Stud
Caulk
CLEANING AND MAINTENANCE
Your American Standard shower base is designed to last indefinitely
with reasonable care and maintenance.
The high-gloss acrylic surface is resistant to impact and retains its luster
with proper care and maintenance. An integral, slip-resistant surface is
incorporated for user safety.
General Cleaning
: Do not use abrasive cleaners; a mixture of warm water
and a mild liquid detergent is adequate for most cleaning.
Strong
detergents formulated for use on tile or porcelain-enamel surfaces
should be avoided.
Caution:
Do not allow liquid detergent containers to remain on base
surfaces for more than a few moments. Do not use Lestoil, Windex, Mr.
Clean, Dow Disinfectant (spray or concentrate), or Lysol Basin, Tub and
Tile Cleaner. Do not allow nail polish remover, dry cleaning fluid, acetone,
paint remover, or other solvents to contact acrylic surface.
Note:
Allow the bedding material to completely harden before
applying weight to the bottom of the shower base.
Tape over the strainer to protect the finish and prevent
construction debris from entering the drain.
Finish installation as shown in Figure G.
E
Lift and lower base over center
of drain pipe and set into place
After leveling base on subfloor, use base and mark studs. This will be
the installed height of shower base. Mix the low-shrink bedding material
(grout, mortar, plaster, etc.).
Concrete is not recommended.
Apply
enough bedding material to support the entire bottom of the shower
base.
The bedding material must not be used under the apron
(front edge).
3
4
5
In the United States:
American Standard Brands
P.O. Box 6820
Piscataway, New Jersey 08855
Attention: Director of Consumer Affairs
For residents of the United States, warranty
information may also be obtained by calling
the following toll free number: (800) 442-1902
www.americanstandard.com
In Canada:
AS Canada ULC
5900 Avebury Rd.
Mississauga, Ontario
Canada L5R 3M3
Toll Free: (800) 387-0369
www.americanstandard.ca
In Mexico:
American Standard B&K Mexico
S. de R.L. de C.
Via Morelos #330
Col. Santa Clara
Ecatepec 55540 Edo. Mexico
Toll Free: 01-800-839-1200
www.americanstandard.com.mx
After the bedding material has been poured and before it sets,
lower the shower base into position with the drain assembly sliding
over the waste pipe as shown in Fig. E. It will be necessary to "rock"
the shower base until the top of the tile flange aligns with the lines
drawn in Step 3 on the stud walls. Make certain the apron is
contacting the rough floor along the entire length of the shower base.
Insure that the base is level in two directions (see Fig. F). Snap
strainer back into place and check for proper drainage.
AS America, Inc. Limited Lifetime Warranty for Shower Bases
AS America, Inc. (”American Standard”) warrants to the original consumer purchaser that
it will, at its option, repair or replace this shower base – American Standard, in its sole
judgment, to be defective under normal residential use and maintenance so long as it is
owned by the original consumer purchaser.
To activate this limited warranty, the purchaser must go online to our website at
www.americanstandard-us.com/warranty to register their shower base within thirty (30)
days of purchase.
In no event will American Standard be liable for the cost of repair or replacement of any
installation materials including but not limited to tile, marble, etc.
This limited warranty does not apply to Commercial Installations. The warranty for
Commercial Installations is three (3) years.
This limited warranty DOES NOT COVER the following:
1. Defect or damages arising from shipping, installation, alterations, accidents, abuse,
misuse, lack of proper maintenance and cleaning as directed in the Installation
Instruction Manual and use of other than genuine American Standard replacement parts,
in all cases whether caused by a plumbing contractor, service company, the owner or
any other person.
2. Deterioration through normal wear and tear and the expense of normal maintenance.
3. Commercial application.
4. Options and accessories. American Standard's limited warranty on these items is
one
year for parts only and excludes labor.
This one year limited warranty covers
accessories manufactured by American Standard (e.g. aprons, drains, grab bars,
heaters, trim kits) against defects of material or workmanship. Warranty coverage begins
on the date the accessory was originally purchased by the owner.
5. Shipping cost for returning products for repairs or replacement under the limited
warranty and labor or other cost incurred in connection with product removal or
installation under this limited warranty.
6. ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES, ALL OF
WHICH ARE HEREBY EXPRESSLY DISCLAIMED, OR THE EXTENSION BEYOND
THE DURATION OF THIS LIMITED WARRANTY OF ANY IMPLIED WARRANTIES,
INCLUDING THOSE OF MERCHANTABILITY OR FITNESS FOR AN INTENDED
PURPOSE. (Some jurisdictions do not allow limitations on how long an implied warranty
lasts, or the exclusion or limitation of incidental or consequential damages, so these
limitations and exclusions may not apply to you.)
7. Responsibility for compliance with local code requirements. (Since local code
requirements vary greatly, distributors, retailers, dealers, installation contractors and
users of plumbing products should determine whether there are any code restrictions on
the installation or use of a specific product.)
This limited warranty gives you specific legal rights. You may have other statutory rights
that vary from state to state or from province to province, in which case this warranty
does not affect such statutory rights.
For service under this warranty, it is suggested that a claim be made through the
contractor or dealer from or through whom the product was purchased, or that a service
request (including a description of the product model and of the defect) be sent to the
following address:
754943-100 Rev. A
LEVEL
LEV
EL
Level base in
two directions.
