allen AT-16, Operations & Parts Manual

Page: 12 / 104

056841 - 01/2013
Page x
Technical Speci fi cations
MODEL AT16
Engine Kohler (27 hp) Electric Start
Payload 2,500 lb. (1,134 kg)
Dimensions (L x H) 97 in. x 50 in. (246 x 127 cm)
Length (with Platform Up) 88.5 in. (225 cm)
Dimensions (Width) 47 in. (119 cm)
Wheelbase / Track Length 51 in. (130 cm)
Bucket Capacity 16 cu. ft. (0.45 cu. m)
Weight 1,475 lb. (669 kg)
Lift Cylinder 2” Diameter (51 mm)
Dump/Return Speed Empty 8 Seconds
Top Speed 6 mph (8 kph)
Fuel Capacity 6 gal. (22.7 L)
The Allen AT-16 Track Drive Power Buggies, are intended for the transportation of concrete and ma-
terial handling. The Track Buggy is equipped with a low dump height which provides clearance and
enables the operator to maneuver over any form height. In addition the Track Buggy has a unique tub
design that reduces concrete splatter outside the polyethylene tub (bucket).
A low center of gravity has been added into the Track Buggy’s design which will provide safety when
maneuvering the buggy in tight areas. A 6-gallon fuel tank allows for extended uninterrupted use. Maxi-
mum speed of the Track Buggy is rated at 6 MPH.
All Track Buggy operators must have training instructions before operating the buggy. For your safety,
warnings are on the buggy and in this manual. Failure to obey these warning can cause severe injury
or even death.
Understand the operation and features of the Track Buggy and what conditions it will be operated in.
Know the rated load capacity, speed range, braking and steering characteristics, turning radius and
operating clearances. Remember that the rain, snow, ice, loose gravel, soft ground, etc., can change
the operating characteristics and capabilities of the Track Buggy.
Inspect the surface over which you will travel. Look for holes, drop offs and obstacles. Look for rough
spots. Look for weak spots on docks, ramps or
fl oor. Look for oil spills, wet spots and slippery surfaces.
Look for soft soil, deep mud and standing water. Watch for anything that might make you lose control or
cause the buggy to tip over.
If, during pre-operation inspection or operation, the buggy is found to be in need of repair or in any way
unsafe, or contributes to an unsafe condition to the operator, the matter shall be reported immediately
to the designated authority, and the buggy shall not be operated until it has been restored to proper
operating condition.
DO NOT make repairs or adjustments unless speci fi cally authorized to do so.