9
firewood value: 16.9 MJ/kg, that is 4.7 kWh/kg
ash content: below 0.7%
DO NOT use the boiler for burning waste.
Always make sure you provide maximum safety.
7.
INSTRUCTIONS FOR BOILER SAFE STARTING AND SAFE
CLEANING
For starting the pellet boiler DO NOT in any case use heating oil, kerosene or similar derivatives and other flammable
liquids. While the boiler is in operation, keep these liquids and other liquids away from it.
Make sure that the pellet boiler is properly installed and that it is not moving.
Make sure that the firebox is tightly closed and will remain closed during boiler operation.
It is necessary to provide access points for measuring the emission and they must be self locking and tight sealed.
Remove ashes only when the pellet boiler is cold.
Do not use abrasive cleaners for cleaning pellet boilers.
ROUTINE MAINTENANCE AND CLEANING
Using a vacuum cleaner to vacuum ashes facilitates the work of removing ashes from the boiler.
Before beginning any maintenance or a cleaning procedure, follow the following safety rules:
Turn the pellet boiler off before beginning any procedure.
Make sure that the boiler is cold before beginning any procedure on the boiler.
Vacuum the ashes deposited in the combustion chamber at least once every ten days, i.e. after consumption of pellets in
the pellet tank (only while the boiler is cold) (Figure 11).
Once a month, open the front bottom door of the heat exchanger on the right side of the boiler and vacuum the interior
(Figure 11).
Always check if the boiler and ashes in it are cold.
The holes on the burner must be clean.
Figure 10
Figure 11
This is a firebox for burning pellets (Figure 10). We recommend you inspect and remove the ashes from the bottom of the
combustion chamber at every cleaning. This is the only way you can ensure that the boiler will work
properly.
For any further information, contact the installer. The manufacturer does not have direct control over the work of
installers and cannot guarantee for any work done or for maintenance works.
The manufacturer does not in any case assume responsibility for damage caused by third parties.
Make sure that the pellet boiler and ashes in it are cold.
