Acucraft Outdoor Linear 8 Burner System, Installation & Operator'S Manual

Page: 5 / 23

5
INSTALLATION GUIDE
5
Note:
The installation of this product must conform with local codes or, in the absence of local codes, the cur-
rent
National Fuel Gas Code - ANZI Z223.1 (NFPA 54)
Installation Code. Please check local codes before
installation.
NOTE TO INSTALLER:
1. This appliance is for OUTDOOR USE ONLY. DO NOT install or use this appliance inside a building, garage
or any other enclosed area, including recreational vehicles and/or boats. This unit must be installed in
such a manner that the combustion air intake at the base of the unit remains clear and free of all ob-
structions at all times and during all weather conditions.
2. FOR NATURAL GAS:
The minimum inlet pressure is 0.25 psi and the maximum inlet gas-supply pressure
is 2.0 psi. The normal operating inlet pressure is 7” WC.
DO NOT INSTALL THIS UNIT IF MINIMUM PRES-
SURE IS NOT AVAILABLE OR IF MAXIMUM PRESSURE IS EXCEEDED.
3. Gas piping system must be sized to provide minimum inlet pressure at the maximum flow rate (BTU/hr).
45,000 to 60,000 BTU’s based on the desired flame height. Undue pressure loss will occur if the pipe is too
small, or the run is too long.
4. The appliance and its appliance main gas valve must be disconnected from the gas supply piping system
during any pressure testing of that system at test pressures in excess of 1/2 psi (3.5 k/Pa). The appliance
must be isolated from the gas valve supply piping system by closing the equipment shutoff valve during any
pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 k/Pa).
• Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appli -
ance.
• WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance
• Do not touch any electrical switch; do not use any phone in your building
• Immediately call gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
• Installation and service must be performed by a qualified installer, service agency or the gas supplier.
WARNING
If the information in these instructions is not followed exactly, a fire or explosion may
result causing property damage, personal injury or loss of life.
SAMPLE