Yanmar 3TNV82A-B, Руководство по обслуживанию

Страница: 106 / 394

PERIODIC MAINTENANCE
5-16
TNV DI Service Manual
Introduction
INTRODUCTION
This section of the Service Manual describes the
procedures for proper care and maintenance of the
engine.
The Importance of Periodic
Maintenance
Engine deterioration and wear occurs in proportion
to length of time the engine has been in service and
the conditions the engine is subject to during
operation. Periodic maintenance prevents
unexpected downtime, reduces the number of
accidents due to poor machine performance and
helps extend the life of the engine.
Performing Periodic Maintenance
Perform periodic maintenance procedures in an
open, level area free from traffic. If possible,
perform the procedures indoors to prevent
environmental conditions, such as rain, wind, or
snow, from damaging the machine.
Yanmar Replacement Parts
Yanmar recommends that you use genuine Yanmar
parts when replacement parts are needed.
Genuine replacement parts help ensure long
engine life.
Required EPA / ARB Maintenance -
USA Only
To maintain optimum engine performance and
compliance with the Environmental Protection
Agency (EPA) Regulations Non-road Engines and
the California Air Resources Board (ARB,
California), it is essential that you follow the
Periodic Maintenance Schedule on page 5-17 and
Periodic Maintenance Procedures on page 5-20.
EPA / ARB Installation
Requirements - USA Only
The following are the installation requirements for
the EPA / ARB. Unless these requirements are met,
the exhaust gas emissions will not be within the
limits specified by the EPA and ARB.
Maximum Exhaust Gas Restriction shall be:
• 3TNV84T, 4TNV84T, 4TNV98T, 4TNV106T:
1.71 psi (11.8kPa, 1200mmAq) or less
• 3TNV82A, 3TNV84, 3TNV88, 4TNV84,
4TNV88, 4TNV94L, 4TNV98, 4TNV106: 2.22
psi (15.3kPa, 1560mmAq) or less
• 4TNV84T-Z, 4TNV98T-Z (With Electronic
Control System EGR): 1.49psi (10.3kPa,
1050mmAq) or less
• 4TNV98-Z(E), 4TNV98T-ZCL: 1.94 psi
(13.4kPa, 1360mmAq) or less
Maximum air intake restriction shall be 0.90 psi
(6.23 kPa; 635 mm Aq) or less. Clean or replace
the air cleaner element if the air intake restriction
exceeds the above mentioned value.
A
WARNING
EXHAUST HAZARD!
• NEVER operate the engine in an
enclosed area such as a garage,
tunnel, underground room, manhole or
ship’s hold without proper ventilation.
• NEVER block windows, vents, or other
means of ventilation if the engine is
operating in an enclosed area. All
internal combustion engines create
carbon monoxide gas during
operation. Accumulation of this gas
within an enclosure could cause
illness or even death.
• Make sure that all connections are
tightened to specifications after repair
is made to the exhaust system.
• Failure to comply could result in death
or serious injury.
0000003en
TNV_DI_SM_A4.book 16 ページ ２００７年１２月６日 木曜日 午前９時２３分