![background image](http://html1.mh-extra.com/html/winnebago/2004-ultimate-freedom/2004-ultimate-freedom_owners-manual_987437084.webp)
SECTION 6
ELECTRICAL SYSTEMS
6-12
BATTERY STORAGE AND
MAINTENANCE
Lead -acid type batteries are electro-chemical
devices for storing and releasing electrical
charge. As such, they are simply an electrical res-
ervoir, not an electrical source. As soon as energy
is removed from the battery, it should be replaced
by the engine alternator or the RV converter sys-
tem.
If a battery sits unused for 30 days or more, es-
pecially during warm weather, it can develop a
deposit of sulfate crystals on the metal plates in-
side the battery. This condition is called sulfation
or sulfating, and prevents the battery from either
releasing or accepting a charge. If this condition
occurs, the battery must be replaced.
If a battery does not contain at least 80%
charge during freezing temperatures, the electro-
lyte can freeze and crack the battery case.
The two best defenses against either sulfating
or insufficient charge are:
1. To disconnect the battery cables to avoid any
“parasitic” discharge, and
2. to check the battery and recharge as neces-
sary at least once a month during long
periods of storage.
A further precaution is to remove the battery
from the vehicle and store it in a cool location on
a wooden or rubber pad, checking charge period-
ically to avoid discharge or sulfating.
To ensure that the battery will always accept
and hold a charge, follow these simple mainte-
nance practices.
·
Make sure the batteries always remain se-
curely clamped in the battery tray.
·
Make sure battery cable clamps are tight on
the terminal posts and are free of corrosion.
·
Neutralize corrosion buildup or acid film on
top of battery by washing with a baking soda/
water solution. Rinse with clear water.
NOTE: Make sure vent caps are on securely to
prevent baking soda solution from enter-
ing the battery and contaminating the
electrolyte fluid.
·
Clean and tighten battery terminals and have
the specific gravity checked at least once a
year.
·
Every two months, or more often in hot
weather, check the battery fluid level. Fill to
approximately 3/8 inch above the plates. DO
NOT OVERFILL. If fluid is added during
freezing weather, the motor home should be
driven several miles to mix water and electro-
lyte to prevent freezing.
·
Fluid level check may be omitted if equipped
with maintenance-free batteries.
Before removing any battery cables
or battery, make sure all 12-volt
equipment in the motor home is off
and the power cord has been discon-
nected.
Replace any damaged cables at once.
Always remove jewelry and wear
protective clothing and eye covering
when checking or handing batteries.
California Proposition 65 Warn-
ing:
Battery posts, terminals and
related accessories contain lead and
lead compounds, chemicals known to
the state of California to cause cancer
and reproductive harm. Wash hands
after handling.
WARNING
WARNING
Содержание 2004 Ultimate Freedom
