![background image](http://html1.mh-extra.com/html/winnebago/2004-ultimate-freedom/2004-ultimate-freedom_owners-manual_987437108.webp)
SECTION 8
APPLIANCES & INTERIOR FEATURES
8-12
Maintaining Your Hydronic System
Maintenance of hydronic systems is impor-
tant to do on an annual basis.
Heat exchanger units need routine cleaning
and vacuuming to ensure that the convective fins
are free from dirt and lint.
The boiler and water heaters require routine
maintenance as recommended by the manufac-
turer.
Because of the complexity of this system we
recommend that you take your coach to your
Ultimate Freedom dealer for annual maintenance
and service, unless you are familiar with heating
systems and electronic controls.
See Chapter 6 of the Hydronic Heating Sys-
tem manual included in your owner InfoCase.
MAINTENANCE SCHEDULE
Troubleshooting Your Hydronic System
If a problem developes with your hydronic
heating system, the diagnostic display on the
remote switch panel will give you a fault code.
You can call the Rixen Enterprises toll-free tech-
nical hotline shown on the control box and they
will guide you through the troubleshooting pro-
cedure. Most problems can be solved over the
phone. Some problems may require an experi-
enced technician. In these situations they will
recommend that you see your dealer for service
or maintenance of the system.
See Chapter 5 of the Hydronic Heating Sys-
tem manual included in your owner InfoCase.
WATER HEATER
The residential fresh water system
water heater is incorporated into the hydronic
heater system. This system provides continuous
1.5 gallons-per-minute of hot water (at approx.
106° F.) following an approximately 3 1/2 min-
utes pre-heat time. This means you can enjoy a
long shower and wash that extra load of laundry
without running out of hot water.
Start-Up
·
Be sure the Water Heater main switch on the
heater control box in the heater compartment
is turned on.
NEVER disconnect battery power to
the hydronic heater using the Battery
Disconnect Switch or circuit breaker
while the heater is operating. Doing
so may cause serious damage to the
heater, which may not be covered
under warranty. Always shut down
the heater using the remote power
switch before using the battery dis-
connect switch.
Maintenance Item
Maintenance
Frequency
Service Required
Fuel/Water Hoses
Seasonally
Inspect for leaks and
Weak Points
Hose Clamps
Seasonally
Inspect for Corrosion
Tighten if Loose
Combustion Chamber
and Exhaust
1,000 hours - primary
maintenance
Vacuum clean
Fuel Filter
Seasonally
Inspect for Cleaning or
Replacement
Nozzles
Distributor Orifice, Air
Slots, and O-Rings
600 Hours - Primary
Maintenance
Cleaning and Inspection
for Wear and Damage
Exhaust System
Seasonally
Inspect for Leaks and
Corrosion
Coolant Mixture
Every 3 years
Replace
Check PH level for
acidity
Electronic Control Panel
Seasonally
Voltage Test/Inspect for
Corroded Wires
CAUTION
Air Compressor
Fuel Pump
Combustion Fan Motor
Seasonally
Inspect for Leaks, Corro-
sion and Wear
Содержание 2004 Ultimate Freedom
