Wacker Neuson DPU 2440F WGB, Руководство оператора

Страница: 13 / 20

T00133GB
11
MOTOR
Starting operating
Check oil level, top up if necessary. Only use high graded brand oil SAE 10 W 40. Fill with oil to upper mark of
the level indicator (1 l).
1. Diesel fuel
Do not use petrol or petrol mixture, also no tractor fuel, but only pure diesel oil. Close fuel tank immediately.
The highest degree of cleannes is also essential here in order to avoid troubles with the injection unit and pre-
mature clogging of the fuel filter. Do not open the supply system or the fuel pump, not even for bleeding. The
fuel pump bleeds itself automatically; thus if the fuel tank is inadvertently run dry; the tank should simply be
refilled and in order to avoid penetration of dirt no loosening dirt no loosening of screws should be taken on at
any part of the fuel system.
2. Dry - type air filter
If the motor starts fuming and the motor power drops simultaneously, then the filter is clogged. Pull out car-
tridge, clean it by tapping lightly to make the dust fall out of the paper element.
With this type of filter the uncleaned air is inside the filter catridge, therefore, make sure that dust particles are
not deposited on the outside, because from there, they could be sucked in by the motor which would lead to
motor damage.
For this reason we recommend replacing the entire cartrige rather than running the risk of incurring damage.
☛
ATTENTION! Clean filter housing, do not use compressed - air. Clean filter housing with a clean cloth.
Make sure that dust from the inside of the housing is not wiped into the opening
of the cylinder.
3. Starting the motor
- Set hand control to full load position.
- Pull down excess starting fuel button.
- Switch on automatic decompression with starter crank.
- Put starter crank over safety cam into gear and start motor.
4. Stopping the motor
- Never switch off motor at full load.
- Reduce speed to idle and allow to run for a short time.
- Put lever at “STOP” and hold it there until motor stops.
Maintenance
- First oil change after 25 hours of operation. Further oil changes every 150 hours.
- Fuel filter does not require any care provided that it is sufficient clear.
- Check valve clearance from time to time.