FIGURE 4B
- BULB REPLACEMENT
NOTE:
It is recommended that the unit be returned to Vector for replacement of the
spotlight bulb. Contact Vector’s Technical Support Department at (954) 584-4446.
NOTE:
When handling a new halogen bulb, do not touch the glass portion of the bulb.
Natural oils from your hands can cause the bulb to fail. If necessary, clean the bulb
with alcohol or a liquid window cleaner.
REPLACING THE AREA LIGHT BULB:
1. This 12volt 0.3 amp quartz halogen bulb is designed to last for the lifetime of
the product.
2. In the event of failure, you may return the spotlight to Vector for bulb replacement.
Contact Vector’s Technical Support Department at (954) 584-4446.
8.
BATTERY
1. The life expectancy of the 12 volt 3.0 Amp-hour, sealed lead-acid battery is
approximately 500 charging cycles. A replacement battery may be purchased
through the Vector Technical Support Department by calling (954) 584-4446
2. A fully-charged battery will provide approximately 22 minutes of continuous light
from the spotlight, or up to16 hours of continuous light from the area utility light
3. Do not allow battery to completely discharge, a dim light indicates that the
battery charge is low, and should be recharged or powered from external
DC source. Charge battery as soon as possible after each use
REPLACING THE BATTERY PACK:
All lead acid batteries fail over time and with extreme temperature changes.
Keeping the battery charged periodically will extend battery life to the maximum.
Recharge after each use as soon as possible using AC/DC recharge adapter as
DC recharge methods may not fully recharge the battery to its full capacity. If the
battery does not operate the spotlight for more than 10 minutes and recharge is
sufficient to fully charge the battery, then it is time to replace the battery.
6
FIGURE 4B -
XTREME SPORT SPOT BATTERY COMPARTMENT
1.
Disconnect the Xtreme Sport Spot
®
2,000,000 from the charging/powering
source.
2. Make sure the trigger switch is turned Off.
3. Lift the battery pack cover and remove it.
4. Carefully disconnect the positive and negative wires from the battery clips,
noting the position of the wires.
5. Follow the directions to replace the quartz halogen bulb in the spotlight to gain
access to the battery from the inside of the spotlight body.
6. Push on the battery from the inside of the body to remove the battery.
7. Set the battery aside and insert the new battery from the rear of the body assembly.
8. Reassemble the spotlight.
9. Place the battery in the compartment taking care to MATCH UP THE PROPER
POLARITY - POSITIVE (red) to positive; negative (black) to negative.
10.
Attach wires to terminals.
11. Make sure battery cover is properly aligned.
12. Test the spotlight by operating the trigger switch. Charge the new battery for
18-20 hours using the AC/DC recharge Aadapter.
BATTERY DISPOSAL:
1. Non-spillable sealed lead-acid battery - This battery is fully recyclable and should
be accepted at any location that accepts common automotive starter batteries.
Examples of places that accept these batteries are: County or municipal recycling
drop-off centers, scrap metal dealers, and retailers who sell automotive replacement
lead acid starter batteries. For more information on recycling this battery,
call toll-free (877) 288-7722.
2. Before disposing of the battery, protect exposed terminals with heavy-duty tape
to prevent shorting (shorting can result in injury or fire).
3. Do not expose battery to fire or intense heat as it may explode.
FUSE REPLACEMENT:
The Xtreme Sport Spot
®
DC power/charging cord is equipped with a 10 amp
cartridge fuse. If this fuse blows, there may be a short circuit in the power cord or
lamp assembly. The fuse will blow if the battery is connected with reverse polarity. The
fuse is accessed by unscrewing (counter-clockwise) the tip of the large DC plug. Check
the fuse with an ohmmeter or other continuity checker. If the fuse is open, investigate
why it blew and correct the problem before replacing the fuse. Reassemble the DC
connector and power the lamp from a 10 amp or greater 12 volt power supply.
5
BATTERY
BATTERY
COVER
BATTERY
CONNECTION